Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
OPEL Meriva B (S10) 1.4 LPG (75), OPEL Meriva B (S10) 1.4 (75), OPEL Meriva B (S10) 1.4 (75), OPEL Meriva B (S10) 1.4 (75), OPEL Meriva B (S10) 1.7 CDTI (75), OPEL Meriva B (S10) 1.3 CDTI (75), OPEL Meriva B (S10) 1.3 CDTI (75), OPEL Meriva B (S10) 1.7 CDTI (75), OPEL Meriva B (S10) 1.7 CDTI (75), OPEL Meriva B (S10) 1.6 CDTI (75), OPEL Meriva B (S10) 1.6 CDTi (75), OPEL Meriva B (S10) 1.6 CDTI (75) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Meriva B (S10) and other OPEL models

Alternative products

Brake pad set

Replacement: brake pads – OPEL MERIVA B. List of the tools you'll need:

                      Wire brush
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      HEX bit No.H7.
                    
                      Wheel impact socket #17
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – OPEL MERIVA B. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – OPEL MERIVA B. Take the following steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – OPEL MERIVA B. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Pull aside the brake caliper retaining spring. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – OPEL MERIVA B. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.

Replacement: brake pads – OPEL MERIVA B. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – OPEL MERIVA B. After applying the spray, wait a few minutes.
Step 14

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake pads – OPEL MERIVA B. Tip:
After applying the spray, wait a few minutes.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – OPEL MERIVA B. Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – OPEL MERIVA B. Tip from AUTODOC experts:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 28 Nm torque.

AUTODOC recommends:
OPEL MERIVA B – Without starting the engine, press the brake pedal several times until it feels firm.
Step 19

Install the dust boot caps of the brake caliper guide pins.
Step 20

Snap the brake caliper retaining spring back into place. Use a crowbar.
Step 21

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – OPEL MERIVA B. AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 23

Install the wheel.

Replacement: brake pads – OPEL MERIVA B. AUTODOC experts recommend:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 24

Screw in the wheel bolts. Use wheel impact socket #17.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 Nm torque.

AUTODOC recommends:
Important! Replacement: brake pads – OPEL MERIVA B. Check the brake fluid level in the reservoir and top up if necessary.
Step 26

Tighten the brake fluid reservoir cap. Close the hood.

Step 27

Remove the jacks and chocks.

Replacement: brake pads – OPEL MERIVA B. Tip:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Meriva B (S10) model

Opel Meriva B tyre size

How to change front brake caliper on OPEL Meriva B (S10) – replacement guide

Free download PDF
2.28 MB
How to change rear brake discs on OPEL Meriva B (S10) – replacement guide

Free download PDF
2.4 MB
How to change front brake discs on OPEL Meriva B (S10) – replacement guide

Free download PDF
1.86 MB
How to change rear brake pads on OPEL Meriva B (S10) – replacement guide

Free download PDF
2.34 MB
How to change rear wheel bearing on OPEL Meriva B (S10) – replacement guide

Free download PDF
2.99 MB
How to change spark plugs on OPEL Meriva B (S10) – replacement guide

Free download PDF
1.25 MB

How to change rear brake pads on OPEL Meriva B (S10) – replacement guide

Free download PDF
2.34 MB
How to change front brake pads on Opel Meriva X03 – replacement guide

Free download PDF
1.69 MB
How to change rear brake pads on Opel Meriva X03 – replacement guide

Free download PDF
1.56 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Opel Corsa D – replacement guide

Free download PDF
1.68 MB
How to change rear brake pads on Opel Astra G F48 – replacement guide

Free download PDF
2.35 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 5 possible reasons your car is shaking or vibrating

6K views

Published on: 14/02/2025
Top 5 reasons why the suspension knocks | AUTODOC tips

2M views

Published on: 09/09/2022
The most common problems when buying a used car | AUTODOC

4K views

Published on: 10/11/2022
How to remove rust | AUTODOC tips

27K views

Published on: 16/09/2021