Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
FIAT Linea (323_, 110_) 1.6 (323.AXF1A), FIAT Linea (323_, 110_) 1.4 T-Jet (323AXC1A), FIAT Linea (323_, 110_) 1.6 D Multijet … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Linea (323_, 110_) and other FIAT models

Brake disc

        Brake disc for Linea (323, 110) Petrol (110 hp)
      
        Brake disc for Linea (323, 110) Petrol (120 hp)
      
        Brake disc for Linea (323, 110) Diesel (105 hp)

Replacement: brake discs – FIAT LINEA (323). List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Drive socket # 12 
                      
                        Drive socket # 13 
                      
                        Drive socket # 19 
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Tap wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake discs – FIAT LINEA (323). AUTODOC recommends:

Replace the brake disks on the car FIAT LINEA (323) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Please note: all work on the car – FIAT LINEA (323) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – FIAT LINEA (323). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Disconnect the brake pad wear sensor plug.

Please note!
Some cars are not equipped with the brake pad wear sensor.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Unscrew the brake caliper fastening. Use a drive socket #13. Use a ratchet wrench.
Step 11

Remove the brake caliper.

Replacement: brake discs – FIAT LINEA (323). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 12

Remove the brake pads. Use a crowbar.
Step 13

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the caliper bracket fastening. Use a drive socket #19. Use a ratchet wrench. Use a tap wrench.
Step 15

Remove the caliper bracket.
Step 16

Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
Step 17

Unscrew the brake disc fastening. Use a drive socket #12. Use a ratchet wrench.
Step 18

Remove the brake disc.
Step 19

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 20

Install the brake disc.
Step 21

Tighten the brake disc fastening. Use a drive socket #12. Use a torque wrench. Tighten it to 10 Nm torque.
Step 22

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – FIAT LINEA (323). After applying the spray, wait a few minutes.
Step 23

Install the brake caliper bracket.
Step 24

Tighten the brake caliper bracket. Use a drive socket #19. Use a torque wrench. Tighten it to 110 Nm torque.
Step 25

Install the brake pads.
Step 26

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake discs – FIAT LINEA (323). Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 27

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 28

Install the brake caliper and fix it. Use a drive socket #13. Use a torque wrench. Tighten it to 30 Nm torque.
Step 29

Connect the brake pad wear sensor plug.
Step 30

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – FIAT LINEA (323). After applying the spray, wait a few minutes.
Step 31

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 32

Install the wheel.

Replacement: brake discs – FIAT LINEA (323). Tip from AUTODOC experts:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 33

Screw in the wheel bolts. Use wheel impact socket #17.
Step 34

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 120 Nm torque.

Replacement: brake discs – FIAT LINEA (323). Professionals recommend:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 35

Tighten the brake fluid reservoir cap. Close the hood.

AUTODOC recommends:
FIAT LINEA (323) – Without starting the engine, press the brake pedal several times until it feels firm.
Step 36

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Linea (323, 110) model.

Fiat Linea 323 tyre size

How to change rear brake discs on FIAT Linea (323_, 110_) – replacement guide

Free download PDF
2.18 MB
How to change front brake pads on FIAT Linea (323, 110) – replacement guide

Free download PDF
1.8 MB
How to change rear wheel bearing on FIAT Linea (323_, 110_) – replacement guide

Free download PDF
2.44 MB
How to change serpentine belt on FIAT Linea (323, 110) – replacement guide

Free download PDF
1.39 MB
How to change spark plugs on FIAT Linea (323_, 110_) – replacement guide

Free download PDF
1.37 MB
How to change front windshield wipers on FIAT Linea (323_, 110_) – replacement guide

Free download PDF
583.68 KB

How to change rear brake discs on FIAT Linea (323_, 110_) – replacement guide

Free download PDF
2.18 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change front brake discs on Fiat Punto 188 – replacement guide

Free download PDF
2.07 MB
How to change rear brake discs on Fiat 500 312 – replacement guide

Free download PDF
2.04 MB
How to change front brake discs on Fiat Punto 199 – replacement guide

Free download PDF
2.19 MB
How to change front brake discs on Fiat Bravo 2 – replacement guide

Free download PDF
2.48 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What to do if the ABS light comes on | AUTODOC tips

6K views

Published on: 11/03/2021
Why do your brakes squeak? | AUTODOC tips

6K views

Published on: 19/01/2021
How to fix your car with AUTODOC CLUB

16K views

Published on: 30/11/2021
How to start a car after a long idle period | AUTODOC tips

6K views

Published on: 20/05/2021