Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VW Passat Saloon (3G2, CB2) 1.8 TSI, VW Passat Saloon (3G2, CB2) 2.0 TSI, VW Passat Saloon (3G2, CB2) 2.0 TSI 4motion, VW Passat Saloon (3G2, CB2) 2.0 TSI 4motion, VW Passat Saloon (3G2, CB2) 2.0 TSI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for Passat Saloon (3G2, CB2) and other VW models

Oil filter

        Oil filter for Passat B8 Saloon (3G2, CB2) Petrol (180 hp)
      
        Oil filter for Passat B8 Saloon (3G2, CB2) Petrol (220 hp)
      
        Oil filter for Passat B8 Saloon (3G2, CB2) Petrol (280 hp)
      
        Oil filter for Passat B8 Saloon (3G2, CB2) Petrol (272 hp)
      
        Oil filter for Passat B8 Saloon (3G2, CB2) Petrol (190 hp)

Replacement: engine oil and filter – VW PASSAT (3G2). List of the tools you'll need:

                        Nylon cleaning brush
                      
                        All-purpose cleaning spray
                      
                        Torque wrench
                      
                        Drive socket # 32
                      
                        Ratchet wrench
                      
                        Flat screwdriver
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – VW PASSAT (3G2). Tip from AUTODOC:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Please note: all work on the car – VW PASSAT (3G2) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Clean the cap of the oil filler neck. Use all-purpose cleaning spray.
Step 4

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 5

Unscrew the oil filler plug.
Step 6

Pull up the oil dipstick.
Step 7

Unscrew the filter housing cap together with the old filter element. Use a drive socket #32. Use a ratchet wrench.
Step 8

Put the old oil filter in the container.
Step 9

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VW PASSAT (3G2). Tip from AUTODOC experts:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
Step 10

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 11

Clean the area of the oil pan drainage hole. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 12

Unscrew the drain plug. Use a flat screwdriver.
Step 13

Drain the used oil.

AUTODOC recommends:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 14

Detach the oil filter from the filter cover.
Step 15

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 16

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 17

Install a new O-ring to its mounting seat on the filter cover.
Step 18

Install the new oil filter to the mounting seat on the filter cover.
Step 19

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 20

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 21

Screw in the new oil drain plug. Use a flat screwdriver.
Step 22

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 23

Lower the car.

Step 24

Install a new oil filter housing cover and tighten it. Use a drive socket #32. Use a torque wrench. Tighten it to 20 Nm torque.
Step 25

Remove the oil filler cap.

Step 26

Insert the funnel.
Step 27

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – VW PASSAT (3G2). AUTODOC experts recommend:
Use the oil recommended by the manufacturer.
Step 28

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 29

Install the oil filler cap.
Step 30

Tighten the oil filler cap.
Step 31

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

AUTODOC recommends:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out.
Step 32

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 33

Remove the fender protection cover.

Step 34

Close the hood.

Replacement: engine oil and filter – VW PASSAT (3G2). AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Passat B8 Saloon (3G2, CB2) model.

Browse tyres

How to change pollen filter on VW Passat B8 Saloon (3G2, CB2) – replacement guide

Free download PDF
778.24 KB
How to change air filter on VW Passat Saloon (3G2, CB2) – replacement guide

Free download PDF
1.01 MB
How to change front brake pads on VW Passat Saloon (3G2, CB2) – replacement guide

Free download PDF
1.58 MB
How to change front brake discs on VW Passat Saloon (3G2, CB2) – replacement guide

Free download PDF
2.19 MB
How to change rear wheel bearing on VW Passat Saloon (3G2, CB2) – replacement guide

Free download PDF
2.22 MB
How to change front wheel bearing on VW Passat Saloon (3G2, CB2) – replacement guide

Free download PDF
2.5 MB

How to change engine oil and filter on VW Passat Saloon (3C2) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat B8 Variant (3G5, CB5) – replacement guide

Free download PDF
1.61 MB
How to change engine oil and filter on VW Passat CC (357) – replacement guide

Free download PDF
1.7 MB
How to change engine oil and filter on VW Passat Variant (365) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat 3C B6 Variant – replacement guide

Free download PDF
2.27 MB
How to change engine oil and filter on VW Passat B7 saloon – replacement guide

Free download PDF
2.8 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

5 common car washing mistakes | AUTODOC tips

5K views

Published on: 23/09/2021
How to paint a brake caliper | AUTODOC tips

10K views

Published on: 08/04/2021
Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023
How to save when buying car parts

2K views

Published on: 03/02/2022