Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VW Passat Saloon (362) 1.6 TDI, VW Passat Saloon (362) 2.0 TDI, VW Passat Saloon (362) 2.0 TDI 4motion, VW Passat Saloon (362) 2.0 TDI, VW Passat Saloon (362) 2.0 TDI 4motion, VW Passat Saloon (362) 2.0 TDI, VW Passat Saloon (362) 2.0 TDI, VW Passat Saloon (362) 2.0 TDI 4motion … View more

The steps may slightly vary depending on the car design.

How to change oil filter and engine oil on VW PASSAT B7 Saloon [TUTORIAL AUTODOC]

All the parts you need to replace – Oil Filter for Passat Saloon (362) and other VW models

Oil filter

        Oil filter for VW Passat Saloon (362) 1.6 TDI Diesel (105 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI Diesel (140 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI 4motion Diesel (140 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI Diesel (170 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI 4motion Diesel (170 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI Diesel (136 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI Diesel (177 hp)
      
        Oil filter for VW Passat Saloon (362) 2.0 TDI 4motion Diesel (177 hp)

Replacement: engine oil and filter – VW Passat B7 saloon. Tools you might need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Torque wrench
                      
                        Drive socket # 19
                      
                        Drive socket # 30
                      
                        Torx bit T30
                      
                        Ratchet wrench
                      
                        Flat screwdriver
                      
                        Funnel
                      
                        Oil drain pan
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – VW Passat B7 saloon. Tip from AUTODOC:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Please note: all work on the car – VW Passat B7 saloon – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Unscrew the bracket for the engine pipes. Use Torx T30. Use a ratchet wrench.
Step 4

Unscrew the oil filler plug.
Step 5

Pull up the oil dipstick.
Step 6

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 7

Unscrew the filter housing cap together with the old filter element. Use a drive socket #30. Use a ratchet wrench.
Step 8

Prepare a container for the old oil filter.
Step 9

Put the old oil filter in the container.
Step 10

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VW Passat B7 saloon. Professionals recommend:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 11

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 12

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 13

Unscrew the drain plug. Use a drive socket #19. Use a ratchet wrench.
Step 14

Drain the used oil.

Replacement: engine oil and filter – VW Passat B7 saloon. Tip from AUTODOC experts:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 15

Detach the oil filter from the filter cover.
Step 16

Remove old o-rings from the oil filter cover. Use a flat screwdriver.
Step 17

Clean the oil filter seat. Use all-purpose cleaning spray.
Step 18

Install new O-rings and a new oil filter to their mounting seats on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 19

Lubricate the rubber seal of the new filter with a little amount of fresh oil.

Step 20

Install a new oil filter housing cover and tighten it.

Step 21

Clean the area of the oil pan drainage hole.
Step 22

Screw in the new drainage plug and tighten it. Use a drive socket #19. Use a torque wrench. Tighten it to 28 nm torque.
Step 23

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 24

Lower the car.
Step 25

Screw the cap on. Use a drive socket #30. Use a torque wrench. Tighten it to 25 Nm torque.
Step 26

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 27

Screw in the bracket for the engine pipes. Use Torx T30. Use a ratchet wrench.
Step 28

Remove the oil filler cap.
Step 29

Insert the funnel.
Step 30

Pour oil into the engine through the filler. Required amount of oil: 4,7 l.

Replacement: engine oil and filter – VW Passat B7 saloon. AUTODOC experts recommend:
Use the oil recommended by the manufacturer.
Step 31

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 32

Install the oil filler cap.
Step 33

Tighten the oil filler cap.
Step 34

Run the engine for a few minutes.
Step 35

After the oil pressure warning light goes out, stop the engine.

Step 36

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 37

Remove the fender protection cover.
Step 38

Close the hood.

Replacement: engine oil and filter – VW Passat B7 saloon. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change fuel filter on VW Passat B7 saloon – replacement guide

Free download PDF
2.02 MB
How to change air filter on VW Passat B7 saloon – replacement guide

Free download PDF
1.77 MB
How to change pollen filter on VW Passat B7 saloon – replacement guide

Free download PDF
1.57 MB
How to change rear brake pads on VW Passat B7 saloon – replacement guide

Free download PDF
2.5 MB
How to change front brake pads on VW Passat B7 saloon – replacement guide

Free download PDF
1.81 MB
How to change rear brake discs on VW Passat B7 saloon – replacement guide

Free download PDF
2.18 MB

How to change engine oil and filter on VW Passat Saloon (3C2) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat B8 Variant (3G5, CB5) – replacement guide

Free download PDF
1.61 MB
How to change engine oil and filter on VW Passat CC (357) – replacement guide

Free download PDF
1.7 MB
How to change engine oil and filter on VW Passat Variant (365) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat 3C B6 Variant – replacement guide

Free download PDF
2.27 MB
How to change engine oil and filter on VW Passat B8 Saloon (3G2, CB2) – replacement guide

Free download PDF
1.61 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to choose the right engine oil for your car | AUTODOC

8K views

Published on: 01/07/2020
What to do if the ABS light comes on | AUTODOC tips

6K views

Published on: 11/03/2021
How to easily repair a punctured tyre | AUTODOC tips

3K views

Published on: 25/02/2021
Top 6 products for enhancing your car | AUTODOC tips

3K views

Published on: 18/11/2021