Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
OPEL Zafira A (T98) 2.2 DTI 16V (F75), OPEL Zafira A (T98) 2.0 DTI 16V (F75), OPEL Zafira A (T98) 2.2 DTI 16V (F75) … View more

The steps may slightly vary depending on the car design.

How to change oil filter and engine oil on OPEL ZAFIRA-A 1 (T98) [TUTORIAL AUTODOC]

Alternative products

Oil filter

Replacement: engine oil and filter – Opel Zafira F75. Tools you'll need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Drive socket # 36 
                    
                      Torx bit T45
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Oil drain pan
                    
                      Funnel
                    
                      Flat Screwdriver
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – Opel Zafira F75. AUTODOC experts recommend:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – Opel Zafira F75. Recommended sequence of steps:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – Opel Zafira F75. Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Put a waste oil container with at least 6 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the drain plug. Use Torx T45. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – Opel Zafira F75. AUTODOC recommends:
Caution! The oil may be hot.
Step 9

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 10

Unscrew the filter housing cap together with the old filter element. Use a drive socket #36. Use a ratchet wrench.
Step 11

Put the old oil filter in the container.

Replacement: engine oil and filter – Opel Zafira F75. Tip from AUTODOC:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 12

Detach the oil filter from the filter cover.
Step 13

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 14

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 15

Remove the oil filter cover O-ring. Use a flat screwdriver.

Step 16

Install new O-rings and a new oil filter to their mounting seats on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 17

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 18

Install a new oil filter housing cover and tighten it. Use a drive socket #36. Use a torque wrench. Tighten it to 25 Nm torque.

AUTODOC recommends:
Wait until the oil has completely drained from the drainage hole.
Step 19

Clean the area of the oil pan drainage hole.
Step 20

Screw in the new drainage plug and tighten it. Use Torx T45. Use a torque wrench. Tighten it to 20 Nm torque.
Step 21

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 22

Lower the car.
Step 23

Remove the oil filler cap.
Step 24

Insert the funnel.
Step 25

Pour oil into the engine through the filler. Required amount of oil: 5.5 l.

Replacement: engine oil and filter – Opel Zafira F75. AUTODOC recommends:
Use the oil recommended by the manufacturer.
Step 26

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 27

Install the oil filler cap.

Step 28

Tighten the oil filler cap.
Step 29

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 30

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 31

Remove the fender protection cover.
Step 32

Close the hood.

Replacement: engine oil and filter – Opel Zafira F75. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Zafira A (T98) model

Opel Zafira f75 tyre size

How to change fuel filter on Opel Zafira F75 – replacement guide

Free download PDF 1.81 MB
How to change air filter on Opel Zafira F75 – replacement guide

Free download PDF 1.85 MB
How to change pollen filter on Opel Zafira F75 – replacement guide

Free download PDF 1.39 MB
How to change rear brake pads on Opel Zafira F75 – replacement guide

Free download PDF 1.8 MB
How to change front brake pads on Opel Zafira F75 – replacement guide

Free download PDF 1.87 MB
How to change front brake discs on Opel Zafira F75 – replacement guide

Free download PDF 2.3 MB

How to change engine oil and filter on Opel Zafira B A05 – replacement guide

Free download PDF 1.95 MB
How to change engine oil and filter on OPEL Zafira C Tourer (P12) – replacement guide

Free download PDF 1.7 MB
How to change engine oil and filter on OPEL ZAFIRA B Van – replacement guide

Free download PDF 1.62 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF 2.82 MB
How to change engine oil and filter on Opel Corsa D – replacement guide

Free download PDF 3.03 MB
How to change engine oil and filter on Opel Corsa C petrol – replacement guide

Free download PDF 1.43 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Motorcycle fuel tank restoration

4K views

Published on: 03/07/2025
How to unlock your car without a key | AUTODOC tips

2M views

Published on: 15/09/2022
Which measuring tools are needed for engine repair?

5K views

Published on: 19/03/2026
Top 5 Mistakes to Avoid for Safe Engine Bay Repairs | AUTODOC Tips

9K views

Published on: 04/08/2023