Recommended replacement interval for the part category Wheel Brake Cylinder : 60000 km

Important!

This replacement procedure can be used for:
VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.4, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.4 TDI, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.6, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Wheel Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) and other VW models

Wheel Brake Cylinder

        Wheel Brake Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (55 hp)
      
        Wheel Brake Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (75 hp)
      
        Wheel Brake Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) Diesel (70 hp)
      
        Wheel Brake Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (101 hp)
      
        Wheel Brake Cylinder for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (60 hp)

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Copper grease 
                      
                        Combination spanner #7
                      
                        Combination spanner #11
                      
                        Torx bit T30
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Flat Screwdriver
                      
                        Phillips screwdriver
                      
                        Wheel chock

Buy tools

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Tip from AUTODOC:

Replace the wheel brake cylinders of the rear drum brakes in pairs.
The replacement procedure is identical for the right and left wheel brake cylinders of the rear drum brakes.
All work should be done with the engine stopped.

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Recommended sequence of steps:

Step 1

Secure the wheels with chocks.
Step 2

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 3

Raise the rear of the car and secure on supports.

Step 4

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW FOX (5Z1, 5Z3)
Step 5

Remove the wheel.
Step 6

Clean the brake drum fasteners. Use a wire brush. Use WD-40 spray.

Step 7

Unscrew the brake drum fastening. Use a Phillips screwdriver.
Step 8

Remove the brake drum.

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Tip from AUTODOC experts:
Examine the brake drum. Replace it if necessary.
Step 9

Disconnect the hydraulic line from the wheel cylinder back. Use a combination spanner #11.

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Tip from AUTODOC:
Immediately plug the brake line open end to prevent fluid leakage and ingress of dirt into the hydraulic system.
Step 10

Unscrew the brake cylinder fastening bolt. Use Torx T30. Use a ratchet wrench.
Step 11

Remove the brake cylinder from the backplate. Use a flat screwdriver.
Step 12

Clean the brake drum. Use a wire brush. Use WD-40 spray.

Step 13

Clean the brake pipe attachment spot and the brake drum fastening bolts on :maker :model.

Step 14

Install a new brake cylinder.
Step 15

Screw the brake cylinder fastening bolts. Use Torx T30. Use a torque wrench. Tighten it to 8 nm torque.
Step 16

Connect the hydraulic line to the wheel cylinder back. Use a combination spanner #11. Use a torque wrench. Tighten it to 14 nm torque.
Step 17

Bleed the brake cylinder system. Use a combination spanner #7.

Replacement: wheel cylinder – VW FOX (5Z1, 5Z3). Professionals recommend:
Make sure to set the protection cap on the bleeder valve.
Step 18

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 19

Install a brake drum.
Step 20

Tigten the brake drum fasteners. Use a Phillips screwdriver. Use a torque wrench. Tighten it to 4 Nm torque.
Step 21

Clean the wheel rim mounting seat. Use a wire brush.

Step 22

Treat the surface where the wheel rim contacts the brake drum. Use copper grease.
Step 23

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. VW FOX (5Z1, 5Z3)
Step 24

Screw in the wheel bolts. Use wheel impact socket #17.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 nm torque.
Step 26

Remove the jacks and chocks.

AUTODOC recommends:
Bleed the brake system after replacing the cylinder on VW FOX (5Z1, 5Z3).Check the brake fluid level in the expansion tank and refill if necessary.Perform test braking when driving at an average speed, the VW FOX (5Z1, 5Z3) should not pull to one side.
Step 27

Adjust the gap between the brake shoes and the drum on :maker :model, pressing the brake pedal 10-15 times.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Fox Hatchback (5Z1, 5Z3, 5Z4) model.

Browse tyres

How to change front brake discs on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.45 MB
How to change front brake hose on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.63 MB
How to change rear brake shoes on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.91 MB
How to change front brake caliper on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.69 MB
How to change front brake pads on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.35 MB
How to change rear wheel bearing on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.25 MB

How to change wheel cylinder on a car – replacement tutorial

Universal

Free download PDF
1.96 MB
How to change wheel cylinder on VW Lupo 6X1 – replacement guide

Free download PDF
1.45 MB
How to change wheel cylinder on VW Polo Hatchback (6N1) – replacement guide

Free download PDF
1.4 MB
How to change wheel cylinder on VW Polo Hatchback (6R1, 6C1) – replacement guide

Free download PDF
1.4 MB
How to change wheel cylinder on VW POLO PLAYA – replacement guide

Free download PDF
1.39 MB
How to change wheel cylinder on VW Polo Saloon (9N4) – replacement guide

Free download PDF
1.39 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to swap the engine on a BMW E30 Turbo | SUPERCAR AUTODOC

2K views

Published on: 15/02/2021
Petrol or diesel? What's the difference between these engines? | AUTODOC

4K views

Published on: 04/05/2021
How to restore a damaged thread | AUTODOC tips

5K views

Published on: 04/05/2023
How to shine your tyres | AUTODOC tips

3K views

Published on: 07/04/2022