Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
VW POLO (9N_) 1.4 16V, VW POLO (9N_) 1.9 TDI, VW POLO (9N_) 1.4 TDI, VW POLO (9N_) 1.4 16V, VW POLO (9N_) 1.2 12V, VW POLO (9N_) 1.9 SDI, VW POLO (9N_) 1.2, VW POLO (9N_) 1.4 16V, VW POLO (9N_) 1.4 FSI, VW POLO (9N_) 1.9 TDI, VW POLO (9N_) 1.4 TDI, VW POLO (9N_) 1.4 TDI, VW POLO (9N_) 1.8 GTI, VW POLO (9N_) 1.6 16V, VW POLO (9N_) 1.8 GTi Cup Edition, VW POLO (9N_) 1.2, VW POLO (9N_) 1.2 12V, VW POLO (9N_) 1.4 … View more

The steps may slightly vary depending on the car design.

How to change fuel filter VW POLO 4 (9N) [TUTORIAL AUTODOC]

All the parts you need to replace – Fuel Filter for POLO (9N_) and other VW models

Alternative products

Fuel filter

Replacement: fuel filter – VW Polo 9N. Tools you'll need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Phillips screwdriver
                    
                      Flat Screwdriver
                    
                      Fluid container

Buy tools

Replacement: fuel filter – VW Polo 9N. AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VW Polo 9N. Recommended sequence of steps:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.
Step 4

Prepare a container for fluids.
Step 5

Clean the fuel filter. Use a wire brush. Use all-purpose cleaning spray.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver.

Replacement: fuel filter – VW Polo 9N. Professionals recommend:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Loosen the fuel filter mounting. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Put the old filter cartridge in the container.

Step 10

Install a new fuel filter.

Replacement: fuel filter – VW Polo 9N. AUTODOC recommends:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – VW Polo 9N.
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 12

Tighten the fuel filter fasteners. Use a Phillips screwdriver.
Step 13

Take the fluid container away from under the fuel filter.
Step 14

Lower the car.
Step 15

Tighten the fuel filler cap.
Step 16

Close the fuel door.

Replacement: fuel filter – VW Polo 9N. AUTODOC experts recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 17

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 18

Shut off the engine.

Replacement: fuel filter – VW Polo 9N. Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Polo IV Hatchback (9N) model

VW Polo Mk4 tyre size

How to change engine oil and filter on VW Polo 9N – replacement guide

Free download PDF
2.34 MB
How to change pollen filter on VW Polo 9N – replacement guide

Free download PDF
1.42 MB
How to change air filter on VW Polo 9N – replacement guide

Free download PDF
1.23 MB
How to change front brake pads on VW Polo 9N – replacement guide

Free download PDF
2.32 MB
How to change rear brake pads on VW Polo 9N – replacement guide

Free download PDF
1.46 MB
How to change front brake discs on VW Polo 9N – replacement guide

Free download PDF
2.46 MB

How to change fuel filter on VW Polo V Hatchback (6R1, 6C1) – replacement guide

Free download PDF
1.74 MB
How to change fuel filter on VW Polo III Hatchback (6N2) – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Polo III Hatchback (6N1) – replacement guide

Free download PDF
1.77 MB
How to change fuel filter on VW Polo Hatchback (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB
How to change fuel filter on VW Polo Coupe (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB
How to change fuel filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
870.4 KB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project

2K views

Published on: 04/03/2021
How to Fix a Squealing Belt: Causes & Solutions | AUTODOC Expert Tips

5K views

Published on: 04/03/2021
TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
Top 5 Mistakes to Avoid for Safe Engine Bay Repairs | AUTODOC Tips

8K views

Published on: 04/08/2023