
Disclaimer
How to change rear brake pads on Mercedes W245 – replacement guide
downloads:
27
Views:
341

Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
MERCEDES-BENZ B-Class (W245) B 170 NGT (245.233), MERCEDES-BENZ B-Class (W245) B 180 NGT (245.233), MERCEDES-BENZ B-Class (W245) B 180 CDI (245.207), MERCEDES-BENZ B-Class (W245) B 200 CDI (245.208), MERCEDES-BENZ B-Class (W245) B 170 (245.232), MERCEDES-BENZ B-Class (W245) B 200 TURBO (245.234), MERCEDES-BENZ B-Class (W245) B 150 (245.231), MERCEDES-BENZ B-Class (W245) B 160 (245.231), MERCEDES-BENZ B-Class (W245) B 180 (245.232), MERCEDES-BENZ B-Class (W245) B 200 CDI (245.208) … View more
The steps may slightly vary depending on the car design.
MERCEDES-BENZ B-Class (W245) B 170 NGT (245.233), MERCEDES-BENZ B-Class (W245) B 180 NGT (245.233), MERCEDES-BENZ B-Class (W245) B 180 CDI (245.207), MERCEDES-BENZ B-Class (W245) B 200 CDI (245.208), MERCEDES-BENZ B-Class (W245) B 170 (245.232), MERCEDES-BENZ B-Class (W245) B 200 TURBO (245.234), MERCEDES-BENZ B-Class (W245) B 150 (245.231), MERCEDES-BENZ B-Class (W245) B 160 (245.231), MERCEDES-BENZ B-Class (W245) B 180 (245.232), MERCEDES-BENZ B-Class (W245) B 200 CDI (245.208) … View more
The steps may slightly vary depending on the car design.
How to change rear brake pads on MERCEDES-BENZ B200 (W245) [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for B-Class (W245) and other MERCEDES-BENZ models
Brake pad set
Alternative products

Wire brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Combination spanner #13
Combination spanner #15
Drive socket # 13
Wheel impact socket #H12
Torque wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – Mercedes W245. AUTODOC experts recommend:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- Please note: all work on the car – Mercedes W245 – should be done with the engine switched off.
Carry out replacement in the following order:
- Step 1Open the bonnet. Unscrew the brake fluid reservoir cap.
- Step 2Secure the wheels with chocks.
- Step 3Loosen the wheel mounting bolts. Use wheel impact socket #H12.
- Step 4Raise the rear of the car and secure on supports.
- Step 5Unscrew the wheel bolts.Replacement: brake pads – Mercedes W245. Tip:To avoid injury, hold up the wheel when unscrewing the bolts.
- Step 6Remove the wheel.
- Step 7Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
- Step 8Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
- Step 9Spread the brake pads. Use a crowbar.
- Step 10Remove the brake caliper.Replacement: brake pads – Mercedes W245. AUTODOC recommends:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
- Step 11Remove the brake pads.Replacement: brake pads – Mercedes W245. Tip from AUTODOC:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
- Step 12Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake pads – Mercedes W245. After applying the spray, wait a few minutes.
- Step 13Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – Mercedes W245. Professionals recommend:Make sure the disc surface is clean before installing the pads.
- Step 14Install new brake pads.Replacement: brake pads – Mercedes W245. Tip from AUTODOC:Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 1
Need New Tyres?
Find out which tyre and wheel sizes are compatible with the MERCEDES-BENZ B-Class (W245) model
Popular maintenance tutorials for W245
Complete guides for changing the Brake pad set on different MERCEDES-BENZ B-CLASS models
Unlock your car maintenance assistant!
Track expenses, manage logs, schedule replacements, and more.
Tips & tricks for your MERCEDES-BENZ B-Class (W245)
View more
- Extend your engine's life: Avoid these 3 damaging factors | AUTODOC tips
- How to remove scratches from car plastic | AUTODOC tips
- 7 signs of faulty fuel injectors | AUTODOC tips
- How to choose the right engine oil for your car | AUTODOC
Most commonly replaced car parts on MERCEDES-BENZ B-CLASS
Time to replace parts? Get even better deals in our Shop app.

SCAN ME