Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
AUDI Q5 SUV Sportback (80A) 40 TFSI Mild Hybrid quattro, AUDI Q5 SUV Sportback (80A) 35 TDI, AUDI Q5 SUV Sportback (80A) 40 TDI quattro … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Q5 SUV Sportback (80A) and other AUDI models

Alternative products

Brake disc

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). Tools you might need:

                      Wire brush
                    
                      Nylon cleaning brush 
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Combination spanner #15
                    
                      Combination spanner #18
                    
                      Drive socket # 13 
                    
                      Drive socket # 18 
                    
                      Torx bit T30
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Impact screwdriver
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). AUTODOC recommends:

Replace the brake disks on the car AUDI Q5 SUV Sportback (80A) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
All work should be done with the engine stopped.

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). Recommended sequence of steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Put the parking brake system into service mode.

Step 3

Secure the wheels with chocks.
Step 4

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 5

Raise the rear of the car and secure on supports.

Step 6

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. AUDI Q5 SUV Sportback (80A)
Step 7

Remove the wheel.
Step 8

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the brake caliper fastening. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
Step 10

Spread the brake pads. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.
Step 13

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the caliper bracket fastening. Use a combination spanner #18.
Step 15

Remove the caliper bracket.
Step 16

Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
Step 17

Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
Step 18

Remove the brake disc.
Step 19

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 20

Install the brake disc.
Step 21

Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 5 Nm torque.
Step 22

Remove the retaining springs of the brake pads.
Step 23

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – AUDI Q5 SUV Sportback (80A). After applying the spray, wait a few minutes.
Step 24

Install the brake caliper bracket.
Step 25

Tighten the brake caliper bracket. Use a drive socket #18. Use a torque wrench. Tighten it to 100 Nm torque.+90°

AUTODOC recommends:
Important! Be sure to use new fasteners.
Step 26

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). Tip:
After applying the spray, wait a few minutes.
Step 27

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 28

Install the retaining springs of the brake pads.
Step 29

Install the brake pads.
Step 30

Install the brake caliper and fix it. Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 31

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 32

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake discs – AUDI Q5 SUV Sportback (80A). Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 33

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. AUDI Q5 SUV Sportback (80A)
Step 34

Screw in the wheel bolts. Use wheel impact socket #17.
Step 35

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 36

Remove the jacks and chocks.
Step 37

Deactivate the service mode of the parking brake system.

AUTODOC recommends:
Important! Replacement: brake discs – AUDI Q5 SUV Sportback (80A). Check the brake fluid level in the reservoir and top up if necessary.
Step 38

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
AUDI Q5 SUV Sportback (80A) – Without starting the engine, press the brake pedal several times until it feels firm.
Step 39

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI Q5 SUV Sportback (80A) model

AUDI Q5 SUV Sportback (80A) tyre size

How to change front windshield wipers on AUDI Q5 SUV Sportback (80A) – replacement guide

Free download PDF
522.24 KB
How to change engine oil and filter on AUDI Q5 SUV Sportback (80A) – replacement guide

Free download PDF
1.61 MB
How to change glow plugs on AUDI Q5 SUV Sportback (80A) – replacement guide

Free download PDF
1.2 MB
How to change water pump & timing belt kit on Audi A4 B7 – replacement guide

Free download PDF
10.39 MB
How to change serpentine belt on Audi A4 B8 – replacement guide

Free download PDF
1.99 MB
How to change engine oil and filter on Audi A3 8PA – replacement guide

Free download PDF
1.78 MB

How to change rear brake discs on AUDI Q5 (8RB) – replacement guide

Free download PDF
2.04 MB
How to change rear brake discs on AUDI Q5 (FYB) – replacement guide

Free download PDF
2.05 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change front brake discs on Audi A4 B8 – replacement guide

Free download PDF
2.29 MB
How to change rear brake discs on Audi A4 B8 – replacement guide

Free download PDF
2.31 MB
How to change rear brake discs on Audi A3 8PA – replacement guide

Free download PDF
1.95 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Revitalize Your Car Interior: DIY Steering Wheel Cover with AUTODOC Tips

6K views

Published on: 14/03/2024
How to fix your car with AUTODOC CLUB

17K views

Published on: 30/11/2021
How to remove rust | AUTODOC tips

27K views

Published on: 16/09/2021
Understanding Car Tools: The Key Differences You Need to Know | AUTODOC tips

8K views

Published on: 16/12/2021