Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
PEUGEOT 607 (9D, 9U) 2.0 HDI, PEUGEOT 307 (3A/C) 2.0 HDi 135, PEUGEOT 307 SW (3H) 2.0 HDi 135, PEUGEOT 807 (E) 2.0 HDI, PEUGEOT 307 CC (3B) 2.0 HDi 135, PEUGEOT 407 (6D_) 2.0 HDi 135, PEUGEOT 307 Break (3E) 2.0 HDi 135, PEUGEOT 407 SW (6E_) 2.0 HDi 135, PEUGEOT 407 Coupe (6C_) 2.0 HDi, PEUGEOT Expert Tepee (VF3X_) 2.0 HDi 140, PEUGEOT EXPERT Box (VF3A_, VF3U_, VF3X_) 2.0 HDi 140, PEUGEOT EXPERT Platform/Chassis 2.0 HDi 140, PEUGEOT 308 I Hatchback (4A_, 4C_) 2.0 HDi, PEUGEOT 308 SW I (4E_, 4H_) 2.0 HDi, PEUGEOT 308 CC (4B_) 2.0 HDi

The steps may slightly vary depending on the car design.

How to change fuel filter PEUGEOT 307 SW [TUTORIAL AUTODOC]

Replacement: fuel filter – Peugeot 307 SW. Tools you might need:

                        All-purpose cleaning spray
                      
                        Drive socket # 27 
                      
                        Ratchet wrench
                      
                        Flat Screwdriver
                      
                        Clip removal tool
                      
                        Hand-operated fluid syringe

                        Fluid container
                      
                        Fender cover

All the parts you need to replace – Fuel Filter for 307 SW (3H) and other PEUGEOT models

    PEUGEOT 307 (3A/C) 2.0 HDi 135
  
    PEUGEOT 407 (6D_) 2.0 HDi 135
  
    PEUGEOT 307 Break (3E) 2.0 HDi 135
  
    PEUGEOT 307 SW (3H) 2.0 HDi 135
  
    PEUGEOT 407 SW (6E_) 2.0 HDi 135
  
    PEUGEOT 307 CC (3B) 2.0 HDi 135
  
    PEUGEOT 607 (9D, 9U) 2.0 HDI
  
    PEUGEOT 807 (E) 2.0 HDI
  
    PEUGEOT Expert Tepee (VF3X_) 2.0 HDi 140
  
    PEUGEOT EXPERT Box (VF3A_, VF3U_, VF3X_) 2.0 HDi 140
  
    PEUGEOT EXPERT Platform/Chassis 2.0 HDi 140
  
    PEUGEOT 308 I Hatchback (4A_, 4C_) 2.0 HDi
  
    PEUGEOT 308 SW I (4E_, 4H_) 2.0 HDi
  
    PEUGEOT 407 Coupe (6C_) 2.0 HDi
  
    PEUGEOT 308 CC (4B_) 2.0 HDi

Replacement: fuel filter – Peugeot 307 SW. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Peugeot 307 SW. Recommended sequence of steps:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Remove the engine cover.

AUTODOC recommends:

Replacement: fuel filter – Peugeot 307 SW. To avoid damaging the part during installation, do not use excessive force.
Step 4

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 5

Detach the fuel pressure sensor connector.Use a flat screwdriver.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing.Use a flat screwdriver.Use a clip removal tool.

Replacement: fuel filter – Peugeot 307 SW. Tip:

Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Close the fuel lines with caps.
Step 8

Unscrew the fasteners of the fuel filter housing cover.Use a drive socket #27.Use a ratchet wrench.
Step 9

Remove the fuel filter cover with the old filter cartridge attached.
Step 10

Prepare a container for fluids.

Step 11

Put the fuel filter cover with the old filter cartridge into a container.
Step 12

Pump the fuel out of the fuel filter housing.Use a hand-operated fluid syringe.
Step 13

Remove the old sealing ring.Use a flat screwdriver.
Step 14

Remove the fuel filter.
Step 15

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 16

Install the new sealing ring.
Step 17

Install a new fuel filter.

Replacement: fuel filter – Peugeot 307 SW. AUTODOC recommends:

Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 18

Install the fuel filter cover with the filter cartridge attached.
Step 19

Tighten the fasteners of the fuel filter cover. Use a drive socket #27.Use a ratchet wrench.Remove the caps from the fuel lines.
Step 20

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 21

Attach the fuel pressure sensor connector.
Step 22

Clean the fuel lines.Use all-purpose cleaning spray.
Step 23

Press the fuel primer pump several times until it gets hard.
Step 24

Install the engine cover and secure it.

Replacement: fuel filter – Peugeot 307 SW. Professionals recommend:

Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 25

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.
Step 26

Shut off the engine.

Step 27

Remove the fender protection cover.
Step 28

Close the hood.

Replacement: fuel filter – Peugeot 307 SW. Tip from AUTODOC:

To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Comments – 10

Tatiana Shurinova

22.07.2021 12:11

Member

hello world
Tatiana Shurinova

22.07.2021 12:12

Member

hello world
Tatiana Shurinova

22.07.2021 12:16

Member

hello world
Tatiana Shurinova

22.07.2021 12:17

Member

hello world
Tatiana Shurinova

22.07.2021 12:17

Member

hello world
Tatiana Shurinova

22.07.2021 12:18

Member

hello world
Tatiana Shurinova

22.07.2021 12:19

Member

hello world
Tatiana Shurinova

22.07.2021 12:21

Member

hello world
Tatiana Shurinova

22.07.2021 12:22

Member

hello world
Adero

31.07.2021 11:52

Member

Hello!

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change engine oil and filter on Peugeot 206 CC 2D – replacement guide

Free download PDF

7.47 MB
How to change fuel filter on Peugeot 206 CC 2D – replacement guide

Free download PDF

4.63 MB
How to change: Peugeot 307 SW pollen filter – replacement guide

Free download PDF

3.64 MB
How to change: Peugeot 307 SW air filter – replacement guide

Free download PDF

4.11 MB
How to change: Peugeot 206 CC 2D spark plugs – replacement guide

Free download PDF

7.33 MB
How to change front brake pads on Peugeot 206 CC 2D – replacement guide

Free download PDF

6.53 MB
How to change track rod end on Peugeot 206 CC 2D – replacement guide

Free download PDF

6.28 MB
How to change: Peugeot 307 SW water pump & timing belt kit – replacement guide

Free download PDF

26.86 MB
How to change: Peugeot 307 SW engine oil and filter – replacement guide

Free download PDF

7.16 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your PEUGEOT 307 SW (3H)

How to check your head gasket | AUTODOC

2K views

Published on: 03/12/2020
What to do if the ABS light comes on | AUTODOC tips

1K views

Published on: 11/03/2021
Coolant comparison test | AUTODOC tips

1K views

Published on: 18/02/2021
What to do if your check engine light is on | AUTODOC tips

5K views

Published on: 19/08/2020