Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
PEUGEOT 806 Van (AF) HDi (AFRHZC) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for 806 Van (AF) and other PEUGEOT models

Fuel filter

Fuel filter for 806 Van (AF) Diesel (109 hp)

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). Tools you need:

                        All-purpose cleaning spray
                      
                        Drive socket # 10 
                      
                        Chain oil filter wrench
                      
                        Flat Screwdriver
                      
                        Crow bar
                      
                        Fender cover

Buy tools

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). Tip from AUTODOC experts:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Warning! Shut down the engine before starting any work – PEUGEOT 806 Kastenwagen (AF)

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the engine cover fastener. Use a drive socket #10.
Step 4

Remove the engine cover.
Step 5

Clean the fuel filter. Use all-purpose cleaning spray.
Step 6

Detach the fuel pressure sensor connector. Use a crowbar.
Step 7

Disconnect the fuel supply lines from the fuel filter. Use a crowbar.

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 8

Loosen the fuel filter mounting. Use a chain oil filter wrench.
Step 9

Remove the fuel filter. Put the old filter cartridge in the container.
Step 10

Detach the old filter cartridge from the filter housing cover. Use a crowbar.
Step 11

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 12

Fasten the fuel filter in the holder.

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). Tip from AUTODOC experts:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.PEUGEOT 806 Kastenwagen (AF) – It's important to only use high-quality filters.
Step 13

Remove the rubber strip. Use a flat screwdriver.
Step 14

Install the rubber strip.
Step 15

Install a new fuel filter.
Step 16

Tighten the fuel filter fasteners.
Step 17

Attach the fuel pressure sensor connector.
Step 18

Connect the fuel supply lines to the fuel filter.

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). AUTODOC experts recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 19

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 20

Shut off the engine.

Step 21

Install the engine cover and secure it.

AUTODOC recommends:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 22

Screw in the engine cover fasteners. Use a drive socket #10.

Step 23

Remove the fender protection cover.

Step 24

Close the hood.

Replacement: fuel filter – PEUGEOT 806 Kastenwagen (AF). Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the PEUGEOT 806 Van (AF) model.

PEUGEOT 806 Kastenwagen (AF) tyre size

How to change engine oil and filter on PEUGEOT 806 Van (AF) – replacement guide

Free download PDF
1.16 MB
How to change air filter on PEUGEOT 806 Van (AF) – replacement guide

Free download PDF
716.8 KB
How to change spark plugs on PEUGEOT 806 Van (AF) – replacement guide

Free download PDF
1.4 MB
How to change front windshield wipers on PEUGEOT 806 Van (AF) – replacement guide

Free download PDF
573.44 KB
How to change water pump & timing belt kit on Peugeot 307 SW – replacement guide

Free download PDF
7.01 MB
How to change serpentine belt on Peugeot 207 hatchback – replacement guide

Free download PDF
1.63 MB

How to change fuel filter on PEUGEOT 806 – replacement guide

Free download PDF
901.12 KB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Peugeot 206 CC 2D – replacement guide

Free download PDF
1.12 MB
How to change fuel filter on Peugeot 307 SW – replacement guide

Free download PDF
1.72 MB
How to change fuel filter on PEUGEOT 207 Hatchback – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on PEUGEOT RCZ Coupe – replacement guide

Free download PDF
931.84 KB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

5 car interior cleaning mistakes | AUTODOC tips

6K views

Published on: 26/05/2022
How to restore a steering wheel | AUTODOC tips

32K views

Published on: 17/02/2022
What to do if your car's air conditioning isn't working properly | AUTODOC tips

6K views

Published on: 05/08/2021
TOP 5 mistakes during DIY oil change | AUTODOC tips

34K views

Published on: 17/06/2021