Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
PEUGEOT 307 SW (3H) 2.0 HDi 135 … View more

The steps may slightly vary depending on the car design.

How to change fuel filter PEUGEOT 307 SW [TUTORIAL AUTODOC]

All the parts you need to replace – Fuel Filter for 307 SW (3H) and other PEUGEOT models

Alternative products

Fuel filter

SKFF-0870022 STARK Fuel filter

5,96 GBP

Shop

9F0023 RIDEX Fuel filter

5,96 GBP

Shop

152071760867 MAGNETI MARELLI Fuel filter

8,42 GBP

Shop

1715695 KRAFT Fuel filter

9,53 GBP

Shop

32508 FEBI BILSTEIN Fuel filter

9,72 GBP

Shop

V42-0055 VAICO Fuel filter

11,70 GBP

Shop

720 951 TOPRAN Fuel filter

13,31 GBP

Shop

E79KP D118 HENGST FILTER Fuel filter

13,62 GBP

Shop

PU 1018 x MANN-FILTER Fuel filter

13,88 GBP

Shop

PE816/5 FILTRON Fuel filter

14,11 GBP

Shop

Replacement: fuel filter – Peugeot 307 SW. Tools you might need:

                      All-purpose cleaning spray
                    
                      Drive socket # 27 
                    
                      Ratchet wrench
                    
                      Flat Screwdriver
                    
                      Clip removal tool
                    
                      Hand-operated fluid syringe

                      Fluid container
                    
                      Fender cover

Buy tools

Replacement: fuel filter – Peugeot 307 SW. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Peugeot 307 SW. Recommended sequence of steps:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Remove the engine cover.

AUTODOC recommends:
Replacement: fuel filter – Peugeot 307 SW. To avoid damaging the part during installation, do not use excessive force.
Step 4

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 5

Detach the fuel pressure sensor connector. Use a flat screwdriver.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver. Use a clip removal tool.

Replacement: fuel filter – Peugeot 307 SW. Tip:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Close the fuel lines with caps.
Step 8

Unscrew the fasteners of the fuel filter housing cover. Use a drive socket #27. Use a ratchet wrench.
Step 9

Remove the fuel filter cover with the old filter cartridge attached.
Step 10

Prepare a container for fluids.

Step 11

Put the fuel filter cover with the old filter cartridge into a container.
Step 12

Pump the fuel out of the fuel filter housing. Use a hand-operated fluid syringe.
Step 13

Remove the old sealing ring. Use a flat screwdriver.
Step 14

Remove the fuel filter.
Step 15

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 16

Install the new sealing ring.
Step 17

Install a new fuel filter.

Replacement: fuel filter – Peugeot 307 SW. AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 18

Install the fuel filter cover with the filter cartridge attached.
Step 19

Tighten the fasteners of the fuel filter cover. Use a drive socket #27. Use a ratchet wrench. Remove the caps from the fuel lines.
Step 20

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 21

Attach the fuel pressure sensor connector.
Step 22

Clean the fuel lines. Use all-purpose cleaning spray.
Step 23

Press the fuel primer pump several times until it gets hard.
Step 24

Install the engine cover and secure it.

Replacement: fuel filter – Peugeot 307 SW. Professionals recommend:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 25

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.
Step 26

Shut off the engine.

Step 27

Remove the fender protection cover.
Step 28

Close the hood.

Replacement: fuel filter – Peugeot 307 SW. Tip from AUTODOC:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the PEUGEOT 307 SW (3H) model

Peugeot 307 SW tyre size

How to change engine oil and filter on Peugeot 307 SW – replacement guide

Free download PDF
1.87 MB
How to change air filter on Peugeot 307 SW – replacement guide

Free download PDF
1.05 MB
How to change pollen filter on Peugeot 307 SW – replacement guide

Free download PDF
901.12 KB
How to change front brake pads on Peugeot 307 SW – replacement guide

Free download PDF
1.68 MB
How to change rear brake pads on Peugeot 307 SW – replacement guide

Free download PDF
1.59 MB
How to change rear brake discs on Peugeot 307 SW – replacement guide

Free download PDF
2.44 MB

How to change fuel filter on PEUGEOT 307 CC (3B) – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on PEUGEOT 307 Hatchback (3A/C) – replacement guide

Free download PDF
1.16 MB
How to change fuel filter on PEUGEOT 307 Estate (3E) – replacement guide

Free download PDF
1.15 MB
How to change fuel filter on PEUGEOT 307 SW Box Body / Estate (3E_, 3H_) – replacement guide

Free download PDF
1.41 MB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Peugeot 206 CC 2D – replacement guide

Free download PDF
1.12 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

#TPMS Explained: Why Your Light is On and How to Respond Safely

8K views

Published on: 28/09/2023
5 possible reasons why your car heater isn't working

6K views

Published on: 21/11/2024
Top Automatic Transmission Blunders You Must Dodge | AUTODOC Insights

7K views

Published on: 26/01/2021
How to choose the right engine oil for your car | AUTODOC

11K views

Published on: 01/07/2020