Recommended replacement interval for the part category Fuel filter : 2 year / 40000 km

Important!

This replacement procedure can be used for:
FIAT Ducato Minibus (250_, 290_) 150 Multijet 3,0 D, FIAT Ducato Minibus (250_, 290_) 130 Multijet 2,3 D, FIAT Ducato Minibus (250_, 290_) 100 Multijet 2,2 D, FIAT Ducato Minibus (250_, 290_) 120 Multijet 2,3 D, FIAT Ducato Minibus (250_, 290_) 160 Multijet 3,0 D, FIAT Ducato Minibus (250_, 290_) 140 Natural Power, FIAT Ducato Minibus (250_, 290_) 160 Multijet 3,0 D, FIAT Ducato Minibus (250_, 290_) 130 Multijet 2,3 D 4x4, FIAT Ducato Minibus (250_, 290_) 160 Multijet 3,0 D 4x4 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Fuel filter

Replacement: fuel filter – FIAT DUCATO Bus (250). Tools you need:

                      Electronic spray
                    
                      Fluid container
                    
                      Fender cover

Buy tools

Replacement: fuel filter – FIAT DUCATO Bus (250). Tip from AUTODOC experts:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Warning! Shut down the engine before starting any work – FIAT DUCATO Bus (250)

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Detach the fuel pressure sensor connector.
Step 4

Unscrew the fuel filter cover.
Step 5

Prepare a container for fluids.
Step 6

Unscrew the filter housing cap together with the old filter element. Put the old filter cartridge in the container.
Step 7

Remove the rubber strip.

Step 8

Take the fuel filter out of the bracket.
Step 9

Fasten the fuel filter in the holder.
Step 10

Install the rubber strip.
Step 11

Install a new fuel filter.

Replacement: fuel filter – FIAT DUCATO Bus (250). AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – FIAT DUCATO Bus (250).
Step 12

Install and tighten the cap of the fuel filter housing.
Step 13

Clean the connector of the fuel pressure sensor. Use electronic spray.
Step 14

Attach the fuel pressure sensor connector.

AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 15

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 16

Shut off the engine.

Step 17

Remove the fender protection cover.

Step 18

Close the hood.

Replacement: fuel filter – FIAT DUCATO Bus (250). AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Ducato III Minibus (250, 290) model

Fiat Ducato 250 Minibus tyre size

How to change engine oil and filter on FIAT Ducato Minibus (250_, 290_) – replacement guide

Free download PDF 2.01 MB
How to change fuel filter on Fiat Doblo Cargo – replacement guide

Free download PDF 2.14 MB
How to change serpentine belt on Fiat Doblo Cargo – replacement guide

Free download PDF 2.43 MB
How to change engine oil and filter on Fiat Punto 199 – replacement guide

Free download PDF 2.37 MB
How to change engine oil and filter on Fiat Panda 169 – replacement guide

Free download PDF 1.91 MB
How to change engine oil and filter on Fiat Doblo Cargo – replacement guide

Free download PDF 2.11 MB

How to change fuel filter on FIAT Ducato III Van (250, 290) – replacement guide

Free download PDF 1.88 MB
How to change fuel filter on FIAT Ducato III Platform / Chassis (250, 290) – replacement guide

Free download PDF 1.9 MB
How to change fuel filter on FIAT Ducato II Platform/Chassis (230) – replacement guide

Free download PDF 1.9 MB
How to change fuel filter on FIAT Ducato II Platform/Chassis (244) – replacement guide

Free download PDF 1.88 MB
How to change fuel filter on FIAT Ducato II Van (244) – replacement guide

Free download PDF 1.9 MB
How to change fuel filter on FIAT Ducato II Van (230L) – replacement guide

Free download PDF 1.92 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to remove rust | AUTODOC tips

27K views

Published on: 16/09/2021
Top 5 possible reasons your car is shaking or vibrating

7K views

Published on: 14/02/2025
Deep interior cleaning | Car transformation by detailing

7K views

Published on: 05/09/2024
Save Money on Fuel with These Easy Tips | AUTODOC

6K views

Published on: 27/09/2022