Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
BMW X3 (E83) xDrive 20 d, BMW X3 (E83) xDrive 18 d, BMW X3 (E83) xDrive 30 d, BMW X3 (E83) xDrive 35 d, BMW X3 (E83) 2.0 d, BMW X3 (E83) 3.0 d, BMW X3 (E83) 3.0 d, BMW X3 (E83) 3.0 sd, BMW X3 (E83) 3.0 d, BMW X3 (E83) xDrive 18 d … View more

The steps may slightly vary depending on the car design.

How to change fuel filter on BMW X3 E83 TUTORIAL | AUTODOC

All the parts you need to replace – Fuel Filter for X3 (E83) and other BMW models

Fuel filter

        Fuel filter for BMW X3 (E83) xDrive 18 d Diesel (143 hp)
      
        Fuel filter for BMW X3 (E83) 3.0 d Diesel (204 hp)
      
        Fuel filter for BMW X3 (E83) xDrive 30 d Diesel (218 hp)
      
        Fuel filter for BMW X3 (E83) 2.0 d Diesel (150 hp)
      
        Fuel filter for BMW X3 (E83) xDrive 35 d Diesel (286 hp)
      
        Fuel filter for BMW X3 (E83) 3.0 d Diesel (218 hp)
      
        Fuel filter for BMW X3 (E83) xDrive 18 d Diesel (136 hp)
      
        Fuel filter for BMW X3 (E83) 3.0 sd Diesel (286 hp)
      
        Fuel filter for BMW X3 (E83) 3.0 d Diesel (211 hp)

Replacement: fuel filter – BMW X3 E83. List of the tools you'll need:

                        Drive socket # 10 
                      
                        Torx bit T20
                      
                        Ratchet wrench
                      
                        Flat Screwdriver
                      
                        Fluid container

Buy tools

Replacement: fuel filter – BMW X3 E83. Tip from AUTODOC:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – BMW X3 E83. Take the following steps:

Step 1

Lift the car using a jack or place it over an inspection pit.
Step 2

Loosen the fuel filter mounting.Use a drive socket #10.Use a ratchet wrench.
Step 3

Prepare a container for fluids.
Step 4

Loosen the fastening clamp of the fuel filter pipe.Use a flat screwdriver.

Replacement: fuel filter – BMW X3 E83. AUTODOC recommends:

Be careful! Fuel may leak from the filter housing and hoses.
Step 5

Disconnect the pipe from the fuel filter.
Step 6

Remove the spring clip that holds the fuel line in place. Use a flat screwdriver.
Step 7

Remove the fuel filter.
Step 8

Unscrew the fastener of the fuel filter holder.Use Torx T20.Use a ratchet wrench.
Step 9

Take the fuel filter out of the bracket.
Step 10

Install the rubber strip.Use a flat screwdriver.
Step 11

Fasten the fuel filter in the holder.
Step 12

Screw in the fastener of the fuel filter bracket.Use Torx T20.Use a ratchet wrench.Use a flat screwdriver.

Replacement: fuel filter – BMW X3 E83. Professionals recommend:

Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 13

Install a new fuel filter.
Step 14

Reinstall the spring clip that holds the fuel line in place.
Step 15

Attach the pipe to the fuel filter.
Step 16

Tighten the fastening clamp of the fuel filter pipe.Use a flat screwdriver.
Step 17

Screw in the fuel filter mounting bracket.Use a drive socket #10.Use a ratchet wrench.
Step 18

Take the fluid container away from under the fuel filter.

Step 19

Lower the car.

Replacement: fuel filter – BMW X3 E83. AUTODOC experts recommend:

Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 20

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.

Step 21

Shut off the engine.

Replacement: fuel filter – BMW X3 E83. Tip from AUTODOC:

To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change air filter on BMW X3 E83 – replacement guide

Free download PDF

1.79 MB
How to change pollen filter on BMW X3 (E83) – replacement guide

Free download PDF

2.22 MB
How to change pollen filter on BMW X3 (E83) – replacement guide

Free download PDF

2.2 MB
How to change engine oil and filter on BMW X3 (E83) – replacement guide

Free download PDF

2.25 MB
How to change front brake pads on BMW X3 E83 – replacement guide

Free download PDF

6.25 MB
How to change rear brake pads on BMW X3 E83 – replacement guide

Free download PDF

6.66 MB

How to change fuel filter on BMW E46 – replacement guide

Free download PDF

1.91 MB
How to change fuel filter on BMW E39 touring – replacement guide

Free download PDF

2.08 MB
How to change fuel filter on BMW E36 – replacement guide

Free download PDF

2.21 MB
How to change fuel filter on BMW E39 – replacement guide

Free download PDF

2.24 MB
How to change fuel filter on BMW E60 – replacement guide

Free download PDF

2.06 MB
How to change fuel filter on BMW E90 diesel – replacement guide

Free download PDF

2.48 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your BMW X3 (E83)

4 reasons why your CHECK ENGINE light is on | AUTODOC

3K views

Published on: 30/03/2022
Checking the starter without removing it | AUTODOC tips

7K views

Published on: 01/12/2020
TOP 8 mistakes car owners make | AUTODOC

12K views

Published on: 09/12/2021
Top 5 mistakes when buying car parts

2K views

Published on: 10/03/2022