Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
BMW X3 (E83) xDrive 20 d, BMW X3 (E83) xDrive 30 d, BMW X3 (E83) 3.0 i xDrive, BMW X3 (E83) 3.0 d, BMW X3 (E83) 2.0 d, BMW X3 (E83) 2.0 i, BMW X3 (E83) 3.0 d, BMW X3 (E83) 3.0 si, BMW X3 (E83) 2.5 si, BMW X3 (E83) 2.0 sd, BMW X3 (E83) xDrive 20 i, BMW X3 (E83) xDrive 30 i, BMW X3 (E83) xDrive 20 d, BMW X3 (E83) xDrive 18 d, BMW X3 (E83) xDrive 30 d … View more

The steps may slightly vary depending on the car design.

How to change front brake pads on BMW X3 E83 [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for X3 (E83) and other BMW models

Brake pad set

        Brake pad set for BMW X3 (E83) xDrive 20 d Diesel (163 hp)
      
        Brake pad set for BMW X3 (E83) xDrive 30 d Diesel (211 hp)
      
        Brake pad set for BMW X3 (E83) 3.0 i xDrive Petrol (231 hp)
      
        Brake pad set for BMW X3 (E83) 3.0 d Diesel (204 hp)
      
        Brake pad set for BMW X3 (E83) 2.0 d Diesel (150 hp)
      
        Brake pad set for BMW X3 (E83) 2.0 i Petrol (150 hp)
      
        Brake pad set for BMW X3 (E83) 3.0 d Diesel (218 hp)
      
        Brake pad set for BMW X3 (E83) 3.0 si Petrol (272 hp)
      
        Brake pad set for BMW X3 (E83) 2.5 si Petrol (218 hp)

Replacement: brake pads – BMW X3 E83. Tools you need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Anti-squeal paste
                      
                        Torque wrench
                      
                        HEX bit No.H7
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – BMW X3 E83. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – BMW X3 E83 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. BMW X3 E83
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Detach the brake caliper retaining spring. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – BMW X3 E83. Tip from AUTODOC:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.

Replacement: brake pads – BMW X3 E83. Professionals recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – BMW X3 E83. After applying the spray, wait a few minutes.
Step 14

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – BMW X3 E83. Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – BMW X3 E83. Tip:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – BMW X3 E83. AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it.
Step 19

Install the brake caliper retaining spring.
Step 20

Tighten the brake caliper fasteners. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 21

Install the dust boot caps of the brake caliper guide pins.
Step 22

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 23

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – BMW X3 E83. After applying the spray, wait a few minutes.
Step 24

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. BMW X3 E83
Step 25

Screw in the wheel bolts. Use wheel impact socket #17.
Step 26

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 140 Nm torque.
Step 27

Remove the jacks and chocks.

Replacement: brake pads – BMW X3 E83. Tip from AUTODOC experts:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and refill if necessary.
Step 28

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – BMW X3 E83. Tip from AUTODOC:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change front brake discs on BMW X3 E83 – replacement guide

Free download PDF
1.94 MB
How to change rear brake pads on BMW X3 E83 – replacement guide

Free download PDF
1.64 MB
How to change rear ABS sensor on BMW X3 E83 – replacement guide

Free download PDF
1.53 MB
How to change front ABS sensor on BMW X3 E83 – replacement guide

Free download PDF
1.29 MB
How to change rear brake discs on BMW X3 E83 – replacement guide

Free download PDF
2.14 MB
How to change front brake caliper on BMW X3 (E83) – replacement guide

Free download PDF
2.13 MB

How to change rear brake pads on BMW X3 E83 – replacement guide

Free download PDF
1.64 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on BMW E90 – replacement guide

Free download PDF
1.7 MB
How to change rear brake pads on BMW E92 – replacement guide

Free download PDF
1.99 MB
How to change front brake pads on BMW E92 – replacement guide

Free download PDF
1.89 MB
How to change rear brake pads on BMW E90 – replacement guide

Free download PDF
1.58 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 mistakes when working in the engine bay | AUTODOC tips

7K views

Published on: 04/08/2023
How to clean an engine bay | AUTODOC

6K views

Published on: 11/09/2020
What to do if your check engine light is on | AUTODOC tips

15K views

Published on: 19/08/2020
5 mistakes made when washing the engine | AUTODOC tips

29K views

Published on: 22/04/2021