Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_) 4.7 4WD (UZN215), TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_) 4.0 (GRN210) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for 4 RUNNER (UZN21_, KZN21_, GRN21_) and other TOYOTA models

Brake pad set

Brake pad set for 4Runner Off-Road (N210) Petrol (264 hp)

Simple DIY car repair steps – Replacing Brake pad set on 4Runner Off-Road (N210)

Brake pad set for 4Runner Off-Road (N210) Petrol (237 hp)

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Tools you need:

                        Wire brush
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Anti-squeal paste
                      
                        Wheel impact socket #21
                      
                        Torque wrench
                      
                        Flat Screwdriver
                      
                        Pin punch
                      
                        Rubber mallet
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Tip from AUTODOC experts:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Take the following steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #21.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake pads fasteners. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). After applying the spray, wait a few minutes.
Step 8

Remove the brake pads retaining clips. Use a crowbar. Use a flat screwdriver.
Step 9

Remove the retainer of the brake pads. Use a pin punch. Use a rubber mallet.
Step 10

Remove the retaining spring of the brake pads.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake pads.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper surface. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Tip:
After applying the spray, wait a few minutes.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 16

Install the retainer of the brake pads. Use a crowbar.
Step 17

Install the retaining spring of the brake pads.
Step 18

Install the brake pads retaining clips.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). After applying the spray, wait a few minutes.
Step 21

Install the wheel.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Tip from AUTODOC experts:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 22

Screw in the wheel bolts. Use wheel impact socket #21.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 112 Nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). Check the brake fluid level in the reservoir and top up if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.
Step 26

Close the hood.

Replacement: brake pads – TOYOTA 4 RUNNER (UZN21_, KZN21_, GRN21_). AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA 4Runner Off-Road (N210) model.

Toyota 4runner UZN210 tyre size

How to change front brake discs on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
2.55 MB
How to change rear brake discs on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
2.3 MB
How to change rear brake pads on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
1.7 MB
How to change air filter on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
972.8 KB
How to change pollen filter on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
860.16 KB
How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB

How to change rear brake pads on TOYOTA 4Runner Off-Road (N210) – replacement guide

Free download PDF
1.7 MB
How to change front brake pads on TOYOTA 4Runner Off-Road (N280) – replacement guide

Free download PDF
1.83 MB
How to change rear brake pads on TOYOTA 4Runner Off-Road (N280) – replacement guide

Free download PDF
1.7 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB
How to change rear brake pads on Toyota Auris E15 – replacement guide

Free download PDF
1.53 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

DIY car soundproofing | AUTODOC tips

76K views

Published on: 15/04/2021
How to remove scratches from a car | AUTODOC tips

7K views

Published on: 12/05/2022
How to unlock your car without a key | AUTODOC tips

858K views

Published on: 15/09/2022
DIY alternator repair | AUTODOC tips

1M views

Published on: 30/11/2022