Disclaimer
How to change front brake pads on NISSAN X-TRAIL (T31) – replacement guide
downloads:
4
Views:
70
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
NISSAN X-TRAIL (T31) 2.0 dCi, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.0 FWD, NISSAN X-TRAIL (T31) 2.0 FWD, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.5, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.0, NISSAN X-TRAIL (T31) 2.5, NISSAN X-TRAIL (T31) 2.5 4x4 … View more
The steps may slightly vary depending on the car design.
NISSAN X-TRAIL (T31) 2.0 dCi, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.0 FWD, NISSAN X-TRAIL (T31) 2.0 FWD, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.0 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.5, NISSAN X-TRAIL (T31) 2.0 dCi 4x4, NISSAN X-TRAIL (T31) 2.5 4x4, NISSAN X-TRAIL (T31) 2.0, NISSAN X-TRAIL (T31) 2.5, NISSAN X-TRAIL (T31) 2.5 4x4 … View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Brake Pads for X-TRAIL (T31) and other NISSAN models
Brake pad set
Brake pad set
Brake pad set for X-Trail (T31) Petrol (140 hp)
Brake pad set for X-Trail (T31) Petrol (140 hp)
Brake pad set for X-Trail (T31) Petrol (137 hp)
Wire brush
Nylon cleaning brush
WD-40 spray
All-purpose cleaning spray
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #17
Drive socket # 14
Wheel impact socket #21
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – NISSAN X-TRAIL (T31). Tip from AUTODOC experts:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- All work should be done with the engine stopped.
Replacement: brake pads – NISSAN X-TRAIL (T31). Take the following steps:
- Step 1Open the bonnet. Unscrew the brake fluid reservoir cap.Step 2Secure the wheels with chocks.Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #21. - Step 4
Raise the front of the car and secure on supports. - Step 5
Unscrew the wheel bolts.AUTODOC recommends:Important! Hold the wheel while unscrewing the fastening bolts. NISSAN X-TRAIL (T31) - Step 6
Remove the wheel. - Step 7
Spread the brake pads. Use a crowbar. - Step 8
Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray. - Step 9
Unscrew the brake caliper fastening. Use a combination spanner #17. Use a drive socket #14. Use a ratchet wrench. - Step 10
Remove the brake caliper.Replacement: brake pads – NISSAN X-TRAIL (T31). Professionals recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary. - Step 11
Remove the brake pads. Use a crowbar.AUTODOC recommends:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced. - Step 12
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use all-purpose cleaning spray. - Step 13
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – NISSAN X-TRAIL (T31). Tip:Make sure the disc surface is clean before installing the pads. - Step 14
Install new brake pads.Replacement: brake pads – NISSAN X-TRAIL (T31). AUTODOC recommends:Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?
Find out which tyre and wheel sizes are compatible with the NISSAN X-Trail (T31) model.
Popular maintenance tutorials for Nissan X-Trail T31
Free download PDF
2.77 MB
Free download PDF1.77 MB
Free download PDF2.13 MB
Free download PDF1.72 MB
Free download PDF3.85 MB
Free download PDF2.02 MB
Complete guides for changing the Brake pad set on different NISSAN X-TRAIL models
Free download PDF1.71 MB
Free download PDF1.7 MB- Free download PDF1.72 MB
Free download PDF1.44 MB
Free download PDF2.84 MB
Free download PDF1.76 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your NISSAN X-TRAIL (T31)
View more
3 things to know before buying summer tyres | AUTODOC tips
Things you should never do with your manual transmission | AUTODOC tips
Top 5 mistakes when buying car parts
5 mistakes made when washing the engine | AUTODOC tips
