Recommended replacement interval for the part category Brake Hose : 50000 km

Important!

This replacement procedure can be used for:
BMW Z4 Roadster (E85) 2.5 i, BMW Z4 Roadster (E85) 2.5 si, BMW Z4 Roadster (E85) 3.0 si, BMW Z4 Roadster (E85) 2.5 si, BMW Z4 Roadster (E85) 2.0 i, BMW Z4 Roadster (E85) 2.2 i, BMW Z4 Roadster (E85) 3.0 i, BMW Z4 Roadster (E85) 2.5 i … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Hose for Z4 Roadster (E85) and other BMW models

Brake Hose

Holding Bracket, brake hose

        Brake Hose for BMW Z4 Roadster (E85) 2.5 si Petrol (218 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 3.0 i Petrol (231 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 3.0 si Petrol (265 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 2.5 i Petrol (192 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 2.5 si Petrol (211 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 2.2 i Petrol (170 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 2.0 i Petrol (150 hp)
      
        Brake Hose for BMW Z4 Roadster (E85) 2.5 i Petrol (177 hp)

Replacement: brake hose – BMW Z4 (E85). Tools you need:

                        Wire brush
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Combination spanner #8
                      
                        Combination spanner #10
                      
                        Combination spanner #14
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Brake bleeder kit
                      
                        Fluid container
                      
                        Wheel chock

Buy tools

Replacement: brake hose – BMW Z4 (E85). AUTODOC experts recommend:

The replacement procedure is identical for the right and left brake hoses on the same axle.
All work should be done with the engine stopped.

Replacement: brake hose – BMW Z4 (E85). Use the following procedure:

Step 1

Open the bonnet.Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts.Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:

Important! Hold the wheel while unscrewing the fastening bolts. BMW Z4 (E85)
Step 6

Remove the wheel.
Step 7

Clean the area where the brake hose is connected to the brake caliper and to the brake circuit pipe.Use a wire brush.Use a brake cleaner.

Replacement: brake hose – BMW Z4 (E85). Tip:

After applying the spray, wait a few minutes.
Step 8

Put a container for gathering brake fluid beneath.
Step 9

Loosen the brake hose fastening.Use a combination spanner #14.Use a ratchet wrench.
Step 10

Detach the brake hose from the shock strut.
Step 11

Unscrew the fastener connecting the brake hose to the brake circuit pipe. Use a combination spanner #10.
Step 12

Unscrew the brake hose from the brake caliper.
Step 13

Screw the new brake hose onto the brake caliper.
Step 14

Fasten the brake hose on the strut.
Step 15

Screw the brake hose onto the brake circuit pipe.
Step 16

Tighten the fastener connecting the brake pipe to the brake caliper.Use a combination spanner #14.Use a torque wrench.Tighten it to 22 Nm torque.
Step 17

Tighten the fastener connecting the brake hose to the brake circuit pipe. Use a combination spanner #10.Use a torque wrench.Tighten it to 14 Nm torque.
Step 18

Clean the brake hose mounting seat on the brake circuit pipe.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake hose – BMW Z4 (E85). After applying the spray, wait a few minutes.
Step 19

Undo the brake bleeder screw.Use a combination spanner #8.
Step 20

Connect the brake bleeder kit to the brake bleeder screw.
Step 21

Press the brake pedal several times to remove any air from the system.
Step 22

Tighten the brake bleeder screw.Use a combination spanner #8.
Step 23

Disconnect the brake bleeder kit.
Step 24

Clean dirt from the brake hose bolt.Use a brake cleaner.

Replacement: brake hose – BMW Z4 (E85). AUTODOC recommends:

After applying the spray, wait a few minutes.
Step 25

Clean the brake disk surface.Use a wire brush.Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 26

Install the wheel.

Replacement: brake hose – BMW Z4 (E85). Tip from AUTODOC experts:

To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 27

Screw in the wheel bolts.Use wheel impact socket #17.
Step 28

Lower the car and working in a cross order, tighten the wheel bolts.Use a torque wrench.Tighten it to 120 Nm torque.
Step 29

Remove the jacks and chocks.
Step 30

Check the brake fluid level in the expansion tank and refill if necessary.

Step 31

Tighten the brake fluid reservoir cap. Close the hood.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change rear brake pads on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

2.77 MB
How to change front brake discs on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

3.1 MB
How to change front brake pad wear sensor on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

2.11 MB
How to change front wheel bearing on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

3.06 MB
How to change front windshield wipers on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

1.44 MB
How to change engine oil and filter on BMW Z4 Roadster (E85) – replacement guide

Free download PDF

2.25 MB

How to change front brake hose on BMW Z4 Coupe (E86) – replacement guide

Free download PDF

2.72 MB
How to change front brake hose on BMW E46 convertible – replacement guide

Free download PDF

2.78 MB
How to change front brake hose on BMW E46 touring – replacement guide

Free download PDF

2.73 MB
How to change front brake hose on BMW 3 Saloon (E46) – replacement guide

Free download PDF

2.73 MB
How to change front brake hose on BMW 3 Compact (E46) – replacement guide

Free download PDF

2.72 MB
How to change front brake hose on BMW 3 Coupe (E46) – replacement guide

Free download PDF

2.73 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your BMW Z4 Roadster (E85)

How to shine your tyres | AUTODOC tips

2K views

Published on: 07/04/2022
Things you should never do with your manual transmission | AUTODOC tips

5K views

Published on: 20/10/2020
How to easily repair a punctured tyre | AUTODOC tips

3K views

Published on: 25/02/2021
How to change automatic transmission fluid | AUTODOC tips

4K views

Published on: 16/09/2020