Recommended replacement interval for the part category Brake caliper : 100000 km

Important!

This replacement procedure can be used for:
BMW Z4 Roadster (E85) 2.5 si, BMW Z4 Roadster (E85) 2.5 si, BMW Z4 Roadster (E85) 2.5 i, BMW Z4 Roadster (E85) 2.0 i, BMW Z4 Roadster (E85) 2.2 i, BMW Z4 Roadster (E85) 2.5 i, BMW Z4 Roadster (E85) 3.0 i … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Calipers for Z4 Roadster (E85) and other BMW models

Brake caliper

        Brake caliper for Z4 Roadster (E85) Petrol (231 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (192 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (170 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (150 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (177 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (218 hp)
      
        Brake caliper for Z4 Roadster (E85) Petrol (211 hp)

Replacement: brake caliper – BMW Z4 (E85). List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Combination spanner #9
                      
                        Flare nut spanner #14
                      
                        HEX bit No.H7.
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Flat Screwdriver
                      
                        Brake bleeder kit
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake caliper – BMW Z4 (E85). Tip from AUTODOC experts:

The replacement procedure is identical for the left and right brake calipers on the same axle.
All work should be done with the engine stopped.

Replacement: brake caliper – BMW Z4 (E85). Take the following steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.

Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake caliper – BMW Z4 (E85). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Detach the brake caliper retaining spring. Use a flat screwdriver.
Step 8

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 9

Clean the area where the brake hose is connected to the caliper, and the guide pins area. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake caliper – BMW Z4 (E85). After applying the spray, wait a few minutes.
Step 10

Loosen the brake hose fastening. Use a flare nut spanner #14.
Step 11

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.

Step 12

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 13

Spread the brake pads. Use a crowbar.
Step 14

Remove the brake caliper.

Replacement: brake caliper – BMW Z4 (E85). AUTODOC recommends:
When replacing the brake caliper, it is recommended to check the brake hose for damages and, if necessary, to replace it with a new one. When replacing a brake caliper it is recommended to replace brake pads, check the state of the brake discs and replace them with new ones if necessary.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 15

Remove the brake pads.
Step 16

Unscrew the brake hose from the brake caliper. Use a flare nut spanner #14.
Step 17

Treat the brake hose. Use a brake cleaner.

Replacement: brake caliper – BMW Z4 (E85). Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 18

Install and fix the brake hose into a new caliper.
Step 19

Install the brake pads.

Replacement: brake caliper – BMW Z4 (E85). AUTODOC experts recommend:
If going to use the old brake pads, clean them.Use a wire brush.
Step 20

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 nm torque.
Step 21

Install the dust boot caps of the brake caliper guide pins.
Step 22

Undo the brake bleeder screw. Use a combination spanner #9.
Step 23

Connect the brake bleeder kit to the brake bleeder screw.
Step 24

Bleed the brake caliper system. Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 25

Disconnect the brake bleeder kit.

Step 26

Tighten the brake caliper bleed screw. Use a combination spanner #9. Use a torque wrench. Tighten it to 10 Nm torque.
Step 27

Clean dirt from the brake hose bolt. Use a brake cleaner.

Replacement: brake caliper – BMW Z4 (E85). Tip:
After applying the spray, wait a few minutes.
Step 28

Install the brake caliper retaining spring. Use a flat screwdriver.
Step 29

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 30

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake caliper – BMW Z4 (E85). After applying the spray, wait a few minutes.
Step 32

Install the wheel.

Replacement: brake caliper – BMW Z4 (E85). Tip from AUTODOC experts:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 33

Screw in the wheel bolts. Use wheel impact socket #17.
Step 34

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 35

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake caliper – BMW Z4 (E85). Check the brake fluid level in the reservoir and top up if necessary.
Step 36

Tighten the brake fluid reservoir cap. Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the BMW Z4 Roadster (E85) model.

Browse tyres

How to change rear brake pads on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
1.78 MB
How to change front brake discs on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
2.15 MB
How to change front brake hose on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
2.72 MB
How to change front brake pads on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
1.62 MB
How to change front brake pad wear sensor on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
2.11 MB
How to change front wheel bearing on BMW Z4 Roadster (E85) – replacement guide

Free download PDF
2.07 MB

How to change brake caliper on a car – replacement tutorial

Universal

Free download PDF
2.91 MB
How to change front brake caliper on BMW E46 – replacement guide

Free download PDF
2.08 MB
How to change rear brake caliper on BMW E39 – replacement guide

Free download PDF
2.98 MB
How to change front brake caliper on BMW X5 E53 – replacement guide

Free download PDF
2.29 MB
How to change front brake caliper on BMW E39 – replacement guide

Free download PDF
2.29 MB
How to change rear brake caliper on BMW X5 E53 – replacement guide

Free download PDF
2.82 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to fix your car with AUTODOC CLUB

16K views

Published on: 30/11/2021
Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023
How to Make a DIY Foam Sprayer | AUTODOC tips

207K views

Published on: 23/06/2022
How to polish an old engine valve cover to a shiny finish | AUTODOC Tips

8K views

Published on: 30/11/2023