Recommended replacement interval for the part category Oil filter : 1 year / 15000 km

Important!

This replacement procedure can be used for:
VOLVO V40 Estate (645) 1.8, VOLVO V40 Estate (645) 2.0, VOLVO V40 Estate (645) 2.0, VOLVO V40 Estate (645) 1.6, VOLVO V40 Estate (645) 1.9 T4, VOLVO V40 Estate (645) 2.0 T, VOLVO V40 Estate (645) 1.6, VOLVO V40 Estate (645) 1.8, VOLVO V40 Estate (645) 2.0 T4, VOLVO V40 Estate (645) 2.0 T, VOLVO V40 Estate (645) 2.0 T, VOLVO V40 Estate (645) 1.8 Bi-Fuel, VOLVO V40 Estate (645) 1.9, VOLVO V40 Estate (645) 1.8 LPG … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for V40 Estate (645) and other VOLVO models

Oil filter

        Oil filter for VOLVO V40 Estate (645) 1.8 Petrol (115 hp)
      
        Oil filter for VOLVO V40 Estate (645) 2.0 Petrol (136 hp)
      
        Oil filter for VOLVO V40 Estate (645) 2.0 Petrol (140 hp)
      
        Oil filter for VOLVO V40 Estate (645) 1.6 Petrol (105 hp)
      
        Oil filter for VOLVO V40 Estate (645) 1.9 T4 Petrol (200 hp)
      
        Oil filter for VOLVO V40 Estate (645) 2.0 T Petrol (160 hp)
      
        Oil filter for VOLVO V40 Estate (645) 1.6 Petrol (109 hp)
      
        Oil filter for VOLVO V40 Estate (645) 1.8 Petrol (122 hp)
      
        Oil filter for VOLVO V40 Estate (645) 2.0 T4 Petrol (200 hp)

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Tools you need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Combination spanner #15
                      
                        Drive socket # 15 
                      
                        Oil filter cup socket 86-14F
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Flat Screwdriver
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Tip from AUTODOC:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Use the following procedure:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 6

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 7

Unscrew the drain plug. Use a combination spanner #15. Use a drive socket #15. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Professionals recommend:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Move the container under the oil filter.
Step 10

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 11

Unscrew the oil filter. Use the 86/14-F socket.
Step 12

Prepare a container for the old oil filter.

Step 13

Put the old oil filter in the container.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Tip from AUTODOC experts:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 14

Detach the oil filter from the filter cover.
Step 15

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 16

Install a new O-ring to its mounting seat on the filter cover.
Step 17

Clean the oil filter seat.
Step 18

Install the new oil filter to the mounting seat on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 19

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 20

Screw the new filter into its place. Use the 86/14-F socket. Use a torque wrench. Tighten it to 25 nm torque.
Step 21

Clean the area of the oil pan drainage hole.
Step 22

Screw in the new drainage plug and tighten it. Use a drive socket #15. Use a torque wrench. Tighten it to 38 nm torque.
Step 23

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 24

Lower the car.

Step 25

Remove the oil filler cap.
Step 26

Insert the funnel.
Step 27

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). Tip from AUTODOC:
Use the oil recommended by the manufacturer.
Step 28

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 29

Install the oil filler cap.
Step 30

Tighten the oil filler cap.
Step 31

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 32

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). AUTODOC recommends:
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 33

Remove the fender protection cover.

Step 34

Close the hood.

Replacement: engine oil and filter – VOLVO V40 Estate (VW). AUTODOC experts recommend:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change fuel filter on VOLVO V40 Estate (VW, 645) – replacement guide

Free download PDF
1.08 MB
How to change fuel filter on Volvo V50 MW – replacement guide

Free download PDF
2.13 MB
How to change engine oil and filter on Volvo V50 MW – replacement guide

Free download PDF
2.92 MB
How to change engine oil and filter on Volvo XC90 1 – replacement guide

Free download PDF
2.67 MB
How to change pollen filter on Volvo V50 MW – replacement guide

Free download PDF
1.66 MB
How to change front wheel bearing on Volvo V70 BW – replacement guide

Free download PDF
4.22 MB

How to change engine oil and filter on VOLVO V40 Hatchback (525, 526) – replacement guide

Free download PDF
2.28 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Volvo XC90 1 – replacement guide

Free download PDF
2.67 MB
How to change engine oil and filter on Volvo V50 MW – replacement guide

Free download PDF
2.92 MB
How to change engine oil and filter on Volvo V70 SW – replacement guide

Free download PDF
1.99 MB
How to change engine oil and filter on Volvo V70 BW – replacement guide

Free download PDF
1.81 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

8 bad driving habits | AUTODOC tips

4K views

Published on: 01/04/2021
What to do if your check engine light is on | AUTODOC tips

15K views

Published on: 19/08/2020
How to choose the right engine oil for your car | AUTODOC

8K views

Published on: 01/07/2020
Coolant comparison test | AUTODOC

11K views

Published on: 18/02/2021