Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
FIAT Fiorino MPV (225) 1.4 (225AXA1A), FIAT Fiorino MPV (225) 1.4 CNG (225AXC1A, 225BXC1A) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for Fiorino MPV (225) and other FIAT models

Oil filter

Oil filter for Fiorino MPV (225) Petrol (77 hp)

Simple DIY car repair steps – Replacing Oil filter on Fiorino MPV (225)

Oil filter for Fiorino MPV (225) Petrol/Compressed Natural Gas (CNG) (77 hp)

Replacement: engine oil and filter – FIAT Fiorino MPV (225). Tools you might need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Torque wrench
                      
                        Oil filter cup socket 65-14F
                      
                        HEX bit No.H12.
                      
                        Ratchet wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – FIAT Fiorino MPV (225). AUTODOC recommends:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Carry out replacement in the following order:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – FIAT Fiorino MPV (225). Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Put a waste oil container with at least 3 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the drain plug. Use HEX No.H12. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – FIAT Fiorino MPV (225). Tip from AUTODOC experts:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Prepare a container for the old oil filter.

Step 10

Clean the oil filter. Use all-purpose cleaning spray.
Step 11

Unscrew the oil filter. Use the 65-14F socket. Use a ratchet wrench.
Step 12

Put the old oil filter in the container.

Replacement: engine oil and filter – FIAT Fiorino MPV (225). Tip from AUTODOC:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 13

Clean the oil filter seat. Use all-purpose cleaning spray.
Step 14

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 15

Screw the new filter into its place. Use the 65-14F socket. Use a torque wrench. Tighten it to 25 Nm torque.
Step 16

Clean the area of the oil pan drainage hole.
Step 17

Screw in the new drainage plug and tighten it. Use HEX No.H12. Use a torque wrench. Tighten it to 22 Nm torque.
Step 18

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 19

Lower the car.

Step 20

Remove the oil filler cap.
Step 21

Insert the funnel.
Step 22

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – FIAT Fiorino MPV (225). AUTODOC recommends:
Use the oil recommended by the manufacturer.
Step 23

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 24

Install the oil filler cap.
Step 25

Tighten the oil filler cap.
Step 26

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 27

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 28

Remove the fender protection cover.

Step 29

Close the hood.

Replacement: engine oil and filter – FIAT Fiorino MPV (225). AUTODOC experts recommend:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Fiorino MPV (225) model.

FIAT Fiorino MPV (225) tyre size

How to change air filter on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
737.28 KB
How to change fuel filter on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
1.15 MB
How to change pollen filter on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
983.04 KB
How to change front brake pads on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
1.61 MB
How to change front brake discs on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
2.29 MB
How to change serpentine belt on FIAT Fiorino MPV (225) – replacement guide

Free download PDF
634.88 KB

How to change engine oil and filter on FIAT FIORINO Box Body / Estate (225) – replacement guide

Free download PDF
1.89 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Fiat Panda 169 – replacement guide

Free download PDF
1.91 MB
How to change engine oil and filter on Fiat Punto 199 – replacement guide

Free download PDF
2.37 MB
How to change engine oil and filter on Fiat 500 312 – replacement guide

Free download PDF
2.25 MB
How to change engine oil and filter on Fiat Bravo 2 – replacement guide

Free download PDF
2.32 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Coolant comparison test | AUTODOC

4K views

Published on: 13/10/2022
How to restore a steering wheel | AUTODOC tips

32K views

Published on: 17/02/2022
How to fix your car with AUTODOC CLUB

16K views

Published on: 30/11/2021
How to prevent car windows from fogging up | AUTODOC tips

12K views

Published on: 04/02/2021