Recommended replacement interval for the part category Oil filter : 1 year / 20000 km

Important!

This replacement procedure can be used for:
ALFA ROMEO GTV (916C_) 2.0 JTS (916CXA00), ALFA ROMEO GTV (916C_) 2.0 T.SPARK 16V (916C2C), ALFA ROMEO GTV (916C_) 1.8 16V (916C3) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Oil filter

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). Tools you might need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Torque wrench
                    
                      Torx bit T50
                    
                      Oil filter cup socket 76-12F
                    
                      Ratchet wrench
                    
                      Funnel
                    
                      Oil drain pan
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). AUTODOC experts recommend:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Please note: all work on the car – ALFA ROMEO GTV (916C_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). AUTODOC experts recommend:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All works should be done with the engine cooled down.
Step 5

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the drain plug. Use Torx T50. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). Tip:
Caution! The oil may be hot.
Step 9

Clean the oil filter. Use all-purpose cleaning spray.
Step 10

Unscrew the oil filter. Use the 76-12F socket. Use a ratchet wrench.
Step 11

Remove the oil filter.

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). Tip from AUTODOC:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 12

Clean the oil filter seat. Use all-purpose cleaning spray.
Step 13

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 14

Install a new oil filter.
Step 15

Tighten the oil filter. Remember to observe the recommended tightening torque. Use the 76-12F socket. Use a torque wrench. Tighten it to 18 Nm torque.

AUTODOC recommends:
Wait until the oil has completely drained from the drainage hole.
Step 16

Clean the area of the oil pan drainage hole.
Step 17

Screw in the new drainage plug and tighten it. Use Torx T50. Use a torque wrench. Tighten it to 20 nm torque.
Step 18

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 19

Lower the car.

Step 20

Remove the oil filler cap.
Step 21

Insert the funnel.
Step 22

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). Tip from AUTODOC:
Use the oil recommended by the manufacturer.
Step 23

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 24

Install the oil filler cap.
Step 25

Tighten the oil filler cap.
Step 26

Run the engine for a few minutes.

Step 27

After the oil pressure warning light goes out, stop the engine.

Step 28

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 29

Remove the fender protection cover.

Step 30

Close the hood.

Replacement: engine oil and filter – ALFA ROMEO GTV (916C_). AUTODOC recommends:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the ALFA ROMEO GTV (916, 916C) model

Alfa Romeo GTV 916 tyre size

How to change front brake pads on ALFA ROMEO GTV (916C_) – replacement guide

Free download PDF
1.63 MB
How to change spark plugs on ALFA ROMEO GTV (916C_) – replacement guide

Free download PDF
1.65 MB
How to change rear suspension strut on ALFA ROMEO GTV (916C_) – replacement guide

Free download PDF
4.58 MB
How to change engine thermostat on ALFA ROMEO GTV (916C_) – replacement guide

Free download PDF
3.4 MB
How to change hand brake cable on ALFA ROMEO GTV (916C_) – replacement guide

Free download PDF
1.37 MB
How to change engine thermostat on Alfa Romeo 147 937 – replacement guide

Free download PDF
3.52 MB

How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Alfa Romeo 159 Sportwagon – replacement guide

Free download PDF
2.24 MB
How to change engine oil and filter on Alfa Romeo 147 937 – replacement guide

Free download PDF
1.89 MB
How to change engine oil and filter on ALFA ROMEO 159 Saloon (939) – replacement guide

Free download PDF
1.79 MB
How to change engine oil and filter on ALFA ROMEO Brera (939) – replacement guide

Free download PDF
1.79 MB
How to change engine oil and filter on ALFA ROMEO Spider (939) – replacement guide

Free download PDF
1.79 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Make a DIY Foam Sprayer | AUTODOC tips

373K views

Published on: 23/06/2022
How I started restoring a driveshaft | Drivetrain restoration – Part 1

8K views

Published on: 17/10/2024
Why Is the Windscreen Washer Not Spraying? Solution

5K views

Published on: 25/04/2025
How to easily repair a punctured tyre | AUTODOC tips

3K views

Published on: 25/02/2021