When to replace the Water Pump + Timing Belt Kit on your AUDI A4
Recommended replacement interval for the part category Water pump and timing belt kit : 70000 km
Important!
This replacement procedure can be used for:
AUDI A4 Convertible (8H7, B6, 8HE, B7) 2.0 TFSI 16V, AUDI A4 Convertible (8H7, B6, 8HE, B7) 2.0 TFSi quattro View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Water Pump + Timing Belt Kit for A4 B7 Convertible (8HE) and other AUDI models
Tools
Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). List of the tools you'll need:
Wire brush
WD-40 spray
All-purpose cleaning spray
Sealant
Torque wrench
Combination spanner #13
Combination spanner #17
Combination spanner #19
Combination spanner #22
Torx bit T20
Torx bit T25
Torx bit T27
12-point socket # 19
Drive socket # 7
Drive socket # 10
Drive socket # 12
Drive socket # 13
HEX bit No.H6
HEX bit No.H8
Wheel impact socket #17
Ratchet wrench
Tap wrench
Clip removal tool
Flat Screwdriver
Phillips screwdriver
Crow bar
Water pump pliers
Clic-R collar pliers
Round-nose pliers
Seal scraper
Funnel
Fluid container
Hydraulic transmission jack
Jack
Painter's tape
Microfibre towel
Fender cover
Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Tip from AUTODOC experts:
  • Follow the terms, recommendations and requirements of the part operation provided by the manufacturer.
  • Warning! Shut down the engine before starting any work – AUDI A4 B7 Cabrio (8HE).
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Unscrew the fasteners of the car battery terminals. Use a drive socket #10. Use a ratchet wrench.
  2. Step 4
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Remove the battery terminals.
  3. Step 5
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Unscrew the coolant reservoir cap.
  4. Step 6
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Loosen the bumper upper fasteners. Use Torx T27. Use a drive socket #10. Use a ratchet wrench.
  5. Step 7
    Lift the car using a jack or place it over an inspection pit.
    Step 8
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Unscrew the wheel bolts. Use wheel impact socket #17.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. AUDI A4 B7 Cabrio (8HE)
  6. Step 9
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 10
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Unscrew and remove the wheel arch cover fasteners. Use Torx T25. Use a ratchet wrench.
  8. Step 11
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Remove the wheel arch cover.
  9. Step 12
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the fastener of the spacer under the bumper reinforcement bar. Use Torx T25. Use a drive socket #10. Use a ratchet wrench.
  10. Step 13
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Unscrew the fastener connecting the bumper to the fenders. Use a drive socket #10. Use a ratchet wrench.
  11. Step 14
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Release the side clips of the bumper. Carefully release the bumper from the fasteners.
  12. Step 15
    Lower the car.
    Step 16
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Unscrew the upper fasteners of the bumper and remove it. Use Torx T27. Use a drive socket #10. Use a ratchet wrench.
  13. Step 17
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Detach the connectors of the fog lights.
  14. Step 18
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Detach the headlamp washer hose.
  15. Step 19
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Unscrew the headlight fasteners. Use Torx T27. Use a ratchet wrench.
  16. Step 20
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Remove the headlight.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Tip from AUTODOC:
    Do not apply excessive force when removing the part. Otherwise you may damage it.
  17. Step 21
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Unplug the connectors of the headlight bulbs. Use a clip removal tool.
  18. Step 22
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Unscrew the headlight fasteners. Use Torx T27. Use a ratchet wrench.
  19. Step 23
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Remove the headlight.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). AUTODOC recommends:
    Do not apply excessive force when removing the part. Otherwise you may damage it.
  20. Step 24
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Unplug the connectors of the headlight bulbs. Use a clip removal tool.
  21. Step 25
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Unplug the horn connector.
  22. Step 26
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Detach the air duct.
  23. Step 27
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Unplug the horn connector.
  24. Step 28
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Remove the air duct.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Tip:
    Do not apply excessive force when removing the part. Otherwise you may damage it.
  25. Step 29
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Unplug the connector of the coolant temperature sensor.
  26. Step 30
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Detach the wiring of the coolant temperature sensor. Use a flat screwdriver.
  27. Step 31
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Unscrew the fasteners of the bumper reinforcement bar. Use a drive socket #13. Use a ratchet wrench.
  28. Step 32
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Remove the bumper reinforcement bar.
  29. Step 33
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Unscrew the fasteners of the radiator air guides. Use Torx T20. Use a ratchet wrench.
  30. Step 34
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Remove the radiator air guides.
  31. Step 35
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Unscrew the fasteners of the hydraulic power steering hoses. Use Torx T20. Use Torx T27. Use a ratchet wrench.
  32. Step 36
    Detach the hydraulic power steering hoses.
    Step 37
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Prepare a container for fluids.
  33. Step 38
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Open the coolant drain tap. Use water pump pliers.
  34. Step 39
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Drain the coolant from the engine.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Professionals recommend:
    Caution! The coolant can be very hot.Wear gloves to prevent contact with hot liquid.All work should be done with the engine stopped.
  35. Step 40
    Close the coolant drain tap.
    Step 41
    Detach the clip of the lower coolant hose. Use a clip removal tool.
    Step 42
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Detach the lower coolant pipe. Use a crowbar.
  36. Step 43
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Detach the air intake hose clamp. Use a drive socket #7. Use a ratchet wrench.
  37. Step 44
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Remove the air intake pipe.
  38. Step 45
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Cover the intercooler air guide with a microfibre cloth to prevent dirt and foreign objects from getting into the system.
  39. Step 46
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Detach the air intake hose clamp. Use a drive socket #7. Use a ratchet wrench.
  40. Step 47
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Clean the air hose fastener. Use all-purpose cleaning spray.
  41. Step 48
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Detach the air intake hose clamp. Use a drive socket #7. Use a ratchet wrench.
  42. Step 49
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Remove the air intake pipe.
  43. Step 50
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Cover the intercooler air guide with a microfibre cloth to prevent dirt and foreign objects from getting into the system.
  44. Step 51
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Prepare a container for fluids.
  45. Step 52
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Loosen the fastener of the hose of the automatic transmission fluid cooling line. Use a combination spanner #19. Use a combination spanner #22.
  46. Step 53
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Detach the hose of the automatic transmission fluid cooling line.
  47. Step 54
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Clean the hose of the automatic transmission fluid cooling line. Use a wire brush. Use all-purpose cleaning spray.
  48. Step 55
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Detach the clamps of the pipes of the automatic transmission fluid cooling line. Use a flat screwdriver.
  49. Step 56
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Remove the pipes of the automatic transmission fluid cooling line.
  50. Step 57
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Close the pipes of the automatic transmission fluid cooling line with caps.
  51. Step 58
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Clean the pipes of the automatic transmission fluid cooling line. Use all-purpose cleaning spray.
  52. Step 59
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Unscrew the fasteners of the air intake duct. Use a Phillips screwdriver.
  53. Step 60
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Remove the air intake duct.
  54. Step 61
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Unplug the connector of the engine cooling fans.
  55. Step 62
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Remove the wiring harness holder.
  56. Step 63
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Unplug the connector of the engine cooling fans.
  57. Step 64
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Detach the clip of the upper coolant hose. Use round-nose pliers.
  58. Step 65
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Detach the upper coolant hose.
  59. Step 66
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Remove the bonnet weather strip.
  60. Step 67
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Unscrew the fasteners of the air conditioning radiator. Use Torx T27. Use a ratchet wrench.
  61. Step 68
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Remove the air conditioning radiator.
  62. Step 69
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Unscrew the fasteners of the engine cooling radiator support panel. Use Torx T27. Use a ratchet wrench.
  63. Step 70
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Remove the bonnet latch cable.
  64. Step 71
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Support the engine in the oil pan area. Use a jack.
  65. Step 72
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Remove the support panel together with the engine cooling radiator.
    AUTODOC recommends:
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Do not use excessive force when removing the part as this may damage it.
  66. Step 73
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Remove the support from under the engine.
  67. Step 74
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Remove the engine cover.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). AUTODOC recommends:
    Raise the engine cover, holding it on two sides simultaneously.Do not apply excessive force when removing the part. Otherwise you may damage it.
  68. Step 75
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Unscrew the fasteners of the front upper timing belt cover. Use a flat screwdriver.
  69. Step 76
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Remove the front upper timing belt cover.
  70. Step 77
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Pull aside the V-ribbed belt tensioner pulley. Use a combination spanner #17.
  71. Step 78
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Remove the V-ribbed belt.
  72. Step 79
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Return the tensioner pulley to its initial position. Use a combination spanner #17.
  73. Step 80
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Unscrew the fastener of the serpentine belt tensioner pulley. Use a drive socket #13. Use a ratchet wrench.
  74. Step 81
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Remove the serpentine belt tensioner pulley.
  75. Step 82
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Unscrew the fastener of the coolant hose clamp. Use HEX No.H6. Use a ratchet wrench.
  76. Step 83
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Loosen the coolant hose clamp. Use clic-R collar pliers.
  77. Step 84
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Detach the coolant hose.
  78. Step 85
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Unscrew the fasteners of the timing belt cover. Use a drive socket #10. Use Torx T27. Use a ratchet wrench.
  79. Step 86
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Remove the timing belt cover.
  80. Step 87
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Clean the crankshaft pulley fasteners. Use a wire brush. Use WD-40 spray.
  81. Step 88
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Unscrew the crankshaft pulley fastener. Use HEX No.H6. Use a ratchet wrench.
  82. Step 89
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Turn the crankshaft gear. Use 12-point socket No.19. Use a tap wrench.
  83. Step 90
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Lock the crankshaft. Use a crowbar.
  84. Step 91
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Remove the crankshaft pulley.
  85. Step 92
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Unscrew the fasteners of the lower timing cover. Use a drive socket #10. Use a ratchet wrench.
  86. Step 93
    Remove the lower timing cover.
    Step 94
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Make a mark on the crankshaft gear.
  87. Step 95
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Make a mark on the camshaft gear.
  88. Step 96
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Make a mark on the timing belt.
  89. Step 97
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Loosen the fastener of the timing belt tensioner pulley. Use a combination spanner #13. Use HEX No.H8.
  90. Step 98
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Unscrew the fastener of the timing belt idler pulley. Use a drive socket #13. Use a ratchet wrench.
  91. Step 99
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Remove the timing belt idler pulley from its mounting seat.
  92. Step 100
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Unscrew the fastener of the timing belt idler pulley. Use a drive socket #12. Use a ratchet wrench.
  93. Step 101
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Remove the timing belt idler pulley from its mounting seat.
  94. Step 102
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Remove the timing belt tensioner pulley.
  95. Step 103
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Remove the timing belt.
  96. Step 104
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Clean the water pump fasteners. Use a wire brush. Use all-purpose cleaning spray.
  97. Step 105
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Unscrew the water pump fasteners. Use a drive socket #10. Use a ratchet wrench.
  98. Step 106
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Remove the water pump.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). AUTODOC experts recommend:
    Caution! Coolant may come out from the water pump channels and body.
  99. Step 107
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Clean the water pump mounting seat. Use a seal scraper. Use all-purpose cleaning spray.
  100. Step 108
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Clean the water pump. Use all-purpose cleaning spray.
  101. Step 109
    Treat the water pump mounting seat. Use a sealant.
    Step 110
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Install the new water pump.
  102. Step 111
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Screw in the water pump fasteners. Use a drive socket #10. Use a ratchet wrench.
  103. Step 112
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Tighten the water pump fasteners. Use a drive socket #10. Use a torque wrench. Tighten it to 15 Nm torque.
  104. Step 113
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Install the new timing belt according to the factory marks.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Tip:
    Be careful not to damage the timing belt.
  105. Step 114
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Install the timing belt tensioner pulley.
  106. Step 115
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Treat the fastening bolt. Use a sealant.
  107. Step 116
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Screw in the fastener of the timing belt tensioner pulley. Use a drive socket #13. Use a ratchet wrench.
  108. Step 117
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Treat the fastening bolt. Use a sealant.
  109. Step 118
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Install the timing belt idler pulley.
  110. Step 119
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Screw in the fastener of the timing belt idler pulley. Use a drive socket #12. Use a ratchet wrench.
  111. Step 120
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Treat the fastening bolt. Use a sealant.
  112. Step 121
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Install the timing belt idler pulley.
  113. Step 122
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Screw in the fastener of the timing belt idler pulley. Use a drive socket #13. Use a ratchet wrench.
  114. Step 123
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Tighten the fastener of the timing belt idler pulley. Use a drive socket #13. Use a torque wrench. Tighten it to 25 Nm torque.
  115. Step 124
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Tighten the fastener of the timing belt idler pulley. Use a drive socket #12. Use a torque wrench. Tighten it to 25 Nm torque.
  116. Step 125
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Adjust the timing belt tension by moving the tensioner pulley. Use a combination spanner #13. Use HEX No.H6.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). Tip from AUTODOC:
    Make sure that the timing belt is properly tensioned.
  117. Step 126
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Remove the crankshaft locking tool.
  118. Step 127
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2006 - tips and tricks
    Turn the crankshaft gear. Use 12-point socket No.19. Use a ratchet wrench.
    Replacement: water pump & timing belt kit – AUDI A4 B7 Cabrio (8HE). AUTODOC recommends:
    Make sure all the timing belt components are mounted correctly.
  119. Step 128
    Step-by-step recommendations for DIY replacement AUDI A4 B7 Cabrio (8HE) 2007 1.8 T Water Pump + Timing Belt Kit
    Tighten the fastener of the timing belt tensioner pulley. Use a drive socket #13. Use a torque wrench. Tighten it to 27 Nm torque.
  120. Step 129
    DIY replacement of Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 1.8 T 2008 is not an issue anymore with our step-by-step tutorial
    Install the lower timing cover.
  121. Step 130
    How to change Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 - free PDF and video manuals
    Tighten the fasteners of the lower timing cover. Use a drive socket #10. Use a torque wrench. Tighten it to 10 Nm torque.
  122. Step 131
    How to replace AUDI A4 B7 Convertible (8HE) 1.8 T 2003 Water Pump + Timing Belt Kit - step-by-step manuals and video guides
    Install the timing belt cover.
  123. Step 132
    AUDI A4 B7 Cabrio (8HE) S4 quattro 2004 Water Pump + Timing Belt Kit replacement: free workshop manuals
    Tighten the timing belt cover fasteners. Use a drive socket #10. Use Torx T27. Use a torque wrench. Tighten it to 10 Nm torque.
  124. Step 133
    Changing Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) S4 quattro 2005 by yourself
    Attach the coolant hose.
  125. Step 134
    How to remove AUDI A4 1.8 T 2006 Water Pump + Timing Belt Kit - online easy-to-follow instructions
    Secure the coolant hose clamp. Use clic-R collar pliers.
  126. Step 135
    How to replace Water Pump + Timing Belt Kit on AUDI A4 B7 Convertible (8HE) 2007: download PDF manuals and video instructions
    Screw in the fastener of the coolant hose clamp. Use HEX No.H6. Use a ratchet wrench.
  127. Step 136
    How hard is it to do yourself: Water Pump + Timing Belt Kit replacement on AUDI A4 B7 Cabrio (8HE) 1.8 T 2008 - download illustrated guide
    Treat the fastening bolts. Use a sealant.
  128. Step 137
    Need to know how to renew Water Pump + Timing Belt Kit on AUDI A4 2009? This free workshop manual will help you to do it yourself
    Install the crankshaft pulley according to the factory marks.
  129. Step 138
    Changing of Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Tighten the crankshaft pulley fastener. Use HEX No.H6. Use a torque wrench. Tighten it to 10 Nm torque.+90°
    AUTODOC recommends:
    Important! Be sure to use new fasteners.
  130. Step 139
    AUDI A4 1.8 T Water Pump + Timing Belt Kit replacement: online guides and video tutorials
    Treat the fastening bolts. Use a sealant.
  131. Step 140
    Replacing Water Pump + Timing Belt Kit on AUDI A4 B7 Cabrio (8HE) 2004 1.8 T by yourself
    Install the serpentine belt tensioner pulley.
  132. Step 141
    A4 B7 Convertible (8HE) 1.8 T 2005 Water Pump + Timing Belt Kit DIY replacement workshop manual
    Tighten the fastener of the serpentine belt tensioner pulley. Use a drive socket #13. Use a torque wrench. Tighten it to 23 Nm torque.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
AUDI A4 B7 Convertible (8HE) Water Pump + Timing Belt Kit replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY AUDI A4 B7 Convertible (8HE) Water Pump + Timing Belt Kit replacement - online guide
Tips & tricks for your AUDI A4 B7 Convertible (8HE)
View more
  • How to change Timing belt kit with water pump on AUDI A4 B7 Convertible (8HE) 1.8 T - replacement tricks
    What to do if the ABS light comes on | AUTODOC tips
  • Changing Cambelt and water pump AUDI A4 B7 Cabrio (8HE) 1.8 T - Replacement Tips
    Coolant comparison test | AUTODOC
  • Maintenance Hacks - AUDI A4 B7 Convertible (8HE) S4 quattro Water pump + timing belt kit replacement guide
    How to remove scratches from a car | AUTODOC tips
  • Replace Timing belt and water pump kit on AUDI A4 B7 Cabrio (8HE) - free video tips
    What causes engine misfire? | AUTODOC

Professional manuals for the most common AUDI models