How to carry out replacement: Brake Shoes 1.8 VW Scirocco 2
Disclaimer
Change VW Scirocco 2 1.8 Brake Shoes yourself – manuals and video tutorials

How to change rear brake shoes on VW SCIROCCO (53B) – replacement guide

downloads: 1
Views: 9
Download your free tutorial and fix VW SCIROCCO (53B) 1.5 problems yourself Download for free 1.91 MB Brake Shoes for VW Scirocco 2 Shop now
Leave a comment Open in a new tab
When to replace the Brake Shoes on your VW SCIROCCO
Recommended replacement interval for the part category Brake Shoe Set : 100000 km
Important!
This replacement procedure can be used for:
VW SCIROCCO (53B) 1.3, VW SCIROCCO (53B) 1.5, VW SCIROCCO (53B) 1.6, VW SCIROCCO (53B) 1.6, VW SCIROCCO (53B) 1.6, VW SCIROCCO (53B) 1.8, VW SCIROCCO (53B) 1.8, VW SCIROCCO (53B) 1.8, VW SCIROCCO (53B) 1.6, VW SCIROCCO (53B) 1.3 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Shoes for SCIROCCO (53B) and other VW models
Alternative products
How to change Brake Shoe Set on VW Scirocco 2 1.8 – step-by-step instructions for straightforward car repair Brake Shoe Set
Tools
Replacement: brake shoes – VW SCIROCCO (53B). List of the tools you'll need:
WD-40 spray
All-purpose cleaning spray
Copper grease
Torque wrench
Drive socket # 30
Wheel impact socket #17
Ratchet wrench
Brake shoe retaining spring compressor
Flat screwdriver
Hammer
Pliers
Round-nose pliers
Water pump pliers
Crow bar
Rubber mallet
Wheel chock
Buy tools
Replacement: brake shoes – VW SCIROCCO (53B). AUTODOC recommends:
  • Replace brake shoes as a set on an axle. This will ensure efficient braking.
  • The replacement procedure is identical for brake shoes on the same axle.
  • Please note: all work on the car – VW SCIROCCO (53B) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Shoes on VW Scirocco 2 1980 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    How to replace VW SCIROCCO (53B) 1.8 1981 Brake Shoes - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VW SCIROCCO (53B)
  3. Step 6
    VW Scirocco 2 1.8 16V 1982 Brake Shoes replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Shoes on VW SCIROCCO (53B) 1.5 1983 by yourself
    Remove the wheel hub nut cap. Use a crowbar. Use a hammer.
  5. Step 8
    How to remove VW SCIROCCO 1.8 1984 Brake Shoes - online easy-to-follow instructions
    Remove the cotter pin securing the hub nut. Use a crowbar. Use a flat screwdriver.
  6. Step 9
    How to replace Brake Shoes on VW SCIROCCO (53B) 1985: download PDF manuals and video instructions
    Unscrew the hub nut. Use a drive socket #30. Use a ratchet wrench.
  7. Step 10
    How hard is it to do yourself: Brake Shoes replacement on VW Scirocco 2 1.6 1986 - download illustrated guide
    Remove the brake drum assembled with the wheel hub bearing.
  8. Step 11
    Need to know how to renew Brake Shoes on VW SCIROCCO 1987? This free workshop manual will help you to do it yourself
    Clean the hub bearing mounting seat. Clean the hub. Use all-purpose cleaning spray.
  9. Step 12
    Changing of Brake Shoes on VW Scirocco 2 1988 won't be an issue if you follow this illustrated step-by-step guide
    Remove the hold-down spring. Use round-nose pliers.
  10. Step 13
    VW SCIROCCO 1.8 Brake Shoes replacement: online guides and video tutorials
    Remove the upper return spring of the brake shoes. Use round-nose pliers.
  11. Step 14
    Replacing Brake Shoes on VW Scirocco 2 1990 1.8 by yourself
    Remove the brake shoe hold-down cup. Use a brake shoe retaining spring compressor.
  12. Step 15
    SCIROCCO (53B) 1.8 1991 Brake Shoes DIY replacement workshop manual
    Compress the wheel cylinder. Use water pump pliers.
  13. Step 16
    How to change Brake Shoes on VW SCIROCCO (53B) 1992 - tips and tricks
    Remove both shoes from the mounting bracket. Use a crowbar.
    Replacement: brake shoes – VW SCIROCCO (53B). Tip from AUTODOC experts:
    Don't press the brake pedal after removing the rear brake drum shoes. This will cause the piston to fall out of the brake cylinder, leakage of brake fluid and depressurization of the system.
  14. Step 17
    Step-by-step recommendations for DIY replacement VW Scirocco 2 1980 1.8 Brake Shoes
    Remove the lower return spring of the brake shoes.
  15. Step 18
    DIY replacement of Brake Shoes on VW SCIROCCO (53B) 1.6 1981 is not an issue anymore with our step-by-step tutorial
    Disconnect the parking brake cable. Use a crowbar.
  16. Step 19
    Remove the brake shoe adjuster lever.
    Step 20
    How to change Brake Shoes on VW Scirocco 2 1980 - free PDF and video manuals
    Connect the parking brake cable to the parking brake lever. Use round-nose pliers.
  17. Step 21
    How to replace VW SCIROCCO (53B) 1.8 1981 Brake Shoes - step-by-step manuals and video guides
    Install the brake shoe adjuster lever.
  18. Step 22
    VW Scirocco 2 1.8 16V 1982 Brake Shoes replacement: free workshop manuals
    Install the brake shoes on the working brake cylinder on the bracket and on the brake-support plate bracket.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Scirocco II (53B) model

VW Scirocco 2 tyre size

Popular maintenance tutorials for VW Scirocco 2

More manuals for VW Scirocco 2

Complete guides for changing the Brake shoe set on different VW SCIROCCO models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VW SCIROCCO (53B) Brake Shoes replacement - online guide
Tips & tricks for your VW SCIROCCO (53B)
View more
  • How to change Brake shoe set on VW SCIROCCO (53B) 1.6 - replacement tricks
    DIY jack restoration | AUTODOC tips
    20K views
    Published on: 22/09/2022
  • Changing Drum brake pads VW Scirocco 2 1.8 - Replacement Tips
    Why Is the Windscreen Washer Not Spraying? Solution
    3K views
    Published on: 25/04/2025
  • Maintenance Hacks - VW SCIROCCO (53B) 1.8 16V Brake shoe kits replacement guide
    Top 5 car noises you shouldn't ignore
    6K views
    Published on: 10/04/2025
  • Replace Drum brake shoe support pads on VW Scirocco 2 - free video tips
    Easy Steps to Fix Minor Scratches on Your Vehicle | AUTODOC tips
    8K views
    Published on: 12/05/2022

Most commonly replaced car parts on VW SCIROCCO

Professional manuals for the most common VW models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VW SCIROCCO (53B) Brake Shoes replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME