When to replace the Brake Pads on your VW TIGUAN
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VW TIGUAN (5N_) 2.0 TDI 4motion, VW TIGUAN (5N_) 1.4 TSI, VW TIGUAN (5N_) 1.4 TSI 4motion, VW TIGUAN (5N_) 2.0 TSI 4motion, VW TIGUAN (5N_) 2.0 TSI 4motion, VW TIGUAN (5N_) 2.0 TDI 4motion, VW TIGUAN (5N_) 2.0 TDI 4motion, VW TIGUAN (5N_) 2.0 TFSI 4motion, VW TIGUAN (5N_) 2.0 TFSI 4motion, VW TIGUAN (5N_) 1.4 TSI 4motion, VW TIGUAN (5N_) 1.4 TSI, VW TIGUAN (5N_) 2.0 TDI, VW TIGUAN (5N_) 2.0 TDI 4motion, VW TIGUAN (5N_) 1.4 TSI, VW TIGUAN (5N_) 2.0 TDI, VW TIGUAN (5N_) 2.0 TDI 4motion View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for TIGUAN (5N_) and other VW models
Tools
Replacement: brake pads – VW TIGUAN (5N_). List of the tools you'll need:
Wire brush
WD-40 spray
Nylon cleaning brush
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #13
Combination spanner #15
Drive socket # 13
Torx bit T27
Wheel impact socket #17
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – VW TIGUAN (5N_). Tip from AUTODOC experts:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – VW TIGUAN (5N_) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Brake Pads on Tiguan Mk1 2007 - free PDF and video manuals
    Connect the scan and service tool.
  2. Step 2
    Put the parking brake system into service mode.
    Step 3
    Open the hood.
    Step 4
    Clean the brake fluid reservoir cap. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW TIGUAN (5N_). After applying the spray, wait a few minutes.
    Step 5
    How to replace VW TIGUAN (5N_) 2.0 TDI 4motion 2008 Brake Pads - step-by-step manuals and video guides
    Unscrew the engine solenoid valve bracket. Use Torx T27. Use a ratchet wrench.
  3. Step 6
    Tiguan Mk1 2.0 TDI 2009 Brake Pads replacement: free workshop manuals
    Unscrew the brake fluid reservoir cap.
  4. Step 7
    Secure the wheels with chocks.
    Step 8
    Changing Brake Pads on VW TIGUAN (5N_) 1.4 TSI 2010 by yourself
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  5. Step 9
    Raise the rear of the car and secure on supports.
    Step 10
    How to remove VW TIGUAN 2.0 TFSI 4motion 2011 Brake Pads - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW TIGUAN (5N_)
  6. Step 11
    How to replace Brake Pads on VW TIGUAN (5N_) 2012: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 12
    How hard is it to do yourself: Brake Pads replacement on Tiguan Mk1 2.0 TDI 2013 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 13
    Need to know how to renew Brake Pads on VW TIGUAN 2014? This free workshop manual will help you to do it yourself
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  9. Step 14
    Changing of Brake Pads on Tiguan Mk1 2015 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
  10. Step 15
    VW TIGUAN 1.4 TSI Brake Pads replacement: online guides and video tutorials
    Remove the brake caliper.
    Replacement: brake pads – VW TIGUAN (5N_). Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 16
    Replacing Brake Pads on Tiguan Mk1 2017 2.0 TDI 4motion by yourself
    Remove the brake pads.
    Replacement: brake pads – VW TIGUAN (5N_). AUTODOC experts recommend:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  12. Step 17
    TIGUAN (5N_) 2.0 TFSI 4motion 2018 Brake Pads DIY replacement workshop manual
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW TIGUAN (5N_). After applying the spray, wait a few minutes.
  13. Step 18
    How to change Brake Pads on VW TIGUAN (5N_) 2007 - tips and tricks
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – VW TIGUAN (5N_). Tip:
    Make sure the disc surface is clean before installing the pads.
  14. Step 19
    Step-by-step recommendations for DIY replacement Tiguan Mk1 2008 2.0 TFSI 4motion Brake Pads
    Install new brake pads.
    Replacement: brake pads – VW TIGUAN (5N_). Tip from AUTODOC experts:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW TIGUAN (5N_) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW TIGUAN (5N_) Brake Pads replacement - online guide
Tips & tricks for your VW TIGUAN (5N_)
View more
  • How to change Brake pad set on VW TIGUAN (5N_) 1.4 TSI 4motion - replacement tricks
    What causes engine misfire? | AUTODOC
  • Changing Disc pads Tiguan Mk1 2.0 TDI 4motion - Replacement Tips
    How to paint a brake caliper | AUTODOC tips
  • Maintenance Hacks - VW TIGUAN (5N_) 2.0 TDI Brake pad kit replacement guide
    How to fix your car with AUTODOC CLUB
  • Replace Disc brake pads on Tiguan Mk1 - free video tips
    How to swap the engine on a BMW E30 Turbo | SUPERCAR AUTODOC