When to replace the Brake Pads on your VW PASSAT
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VW Passat Variant (33B) 2.2 Syncro, VW Passat Variant (33B) 2.2, VW Passat Variant (33B) 2.0 Syncro, VW Passat Variant (33B) 2.2 Syncro View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Tools
Replacement: brake pads – VW PASSAT Variant (32B). Tools you'll need:
Wire brush
Brake cleaner
Anti-squeal paste
Copper grease
Combination spanner #15
Drive socket # 13
Wheel impact socket #17
Ratchet wrench
Torque wrench
Wheel chock
Replacement: brake pads – VW PASSAT Variant (32B). AUTODOC recommends:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – VW PASSAT Variant (32B) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Pads on VW Passat 32B 1980 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace VW Passat Variant (33B) 1.8 1981 Brake Pads - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    VW Passat 32B 1.6 D 1982 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VW PASSAT Variant (32B)
  4. Step 6
    Changing Brake Pads on VW Passat Variant (33B) 1.6 1983 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VW PASSAT 2.2 1984 Brake Pads - online easy-to-follow instructions
    Unscrew the brake caliper fastening. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
  6. Step 8
    How to replace Brake Pads on VW Passat Variant (33B) 1985: download PDF manuals and video instructions
    Remove the brake caliper.
    Replacement: brake pads – VW PASSAT Variant (32B). Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  7. Step 9
    How hard is it to do yourself: Brake Pads replacement on VW Passat 32B 2.0 1986 - download illustrated guide
    Remove the brake pads.
    Replacement: brake pads – VW PASSAT Variant (32B). AUTODOC experts recommend:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  8. Step 10
    Need to know how to renew Brake Pads on VW PASSAT 1987? This free workshop manual will help you to do it yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW PASSAT Variant (32B). After applying the spray, wait a few minutes.
  9. Step 11
    Changing of Brake Pads on VW Passat 32B 1988 won't be an issue if you follow this illustrated step-by-step guide
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – VW PASSAT Variant (32B). Professionals recommend:
    Make sure the disc surface is clean before installing the pads.
  10. Step 12
    VW PASSAT 1.6 D Brake Pads replacement: online guides and video tutorials
    Install new brake pads.
    Replacement: brake pads – VW PASSAT Variant (32B). AUTODOC recommends:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW Passat Variant (33B) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW Passat Variant (33B) Brake Pads replacement - online guide
Tips & tricks for your VW Passat Variant (33B)
View more
  • How to change Brake pad set on VW Passat Variant (33B) 1.6 TD - replacement tricks
    5 common car washing mistakes | AUTODOC tips
  • Changing Disc pads VW Passat 32B 1.8 - Replacement Tips
    DIY alternator repair | AUTODOC tips
  • Maintenance Hacks - VW Passat Variant (33B) 1.6 D Brake pad kit replacement guide
    Coolant comparison test | AUTODOC
  • Replace Disc brake pads on VW Passat 32B - free video tips
    5 most common causes of oil leaks | AUTODOC tips