Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VOLVO C70 II Convertible (542) D3, VOLVO C70 II Convertible (542) D4, VOLVO C70 II Convertible (542) 2.4, VOLVO C70 II Convertible (542) 2.4 i, VOLVO C70 II Convertible (542) T5, VOLVO C70 II Convertible (542) D5, VOLVO C70 II Convertible (542) T5, VOLVO C70 II Convertible (542) 2.0 D, VOLVO C70 II Convertible (542) 2.4 D … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for C70 II Convertible (542) and other VOLVO models

Alternative products

Brake pad set

Replacement: brake pads – VOLVO C70 II Convertible. List of the tools you'll need:

                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      HEX bit no.H7.
                    
                      Wheel impact socket #19
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – VOLVO C70 II Convertible. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – VOLVO C70 II Convertible. Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VOLVO C70 II Convertible
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Detach the brake caliper retaining spring. Use a crowbar.
Step 10

Remove the brake caliper. Use a crowbar.

Replacement: brake pads – VOLVO C70 II Convertible. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

Replacement: brake pads – VOLVO C70 II Convertible. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VOLVO C70 II Convertible. After applying the spray, wait a few minutes.
Step 13

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VOLVO C70 II Convertible. Tip:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – VOLVO C70 II Convertible. AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 16

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 35 Nm torque.
Step 17

Install the dust boot caps of the brake caliper guide pins.
Step 18

Install the brake caliper retaining spring. Use a rubber mallet.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – VOLVO C70 II Convertible. Professionals recommend:
After applying the spray, wait a few minutes.
Step 21

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. VOLVO C70 II Convertible
Step 22

Screw in the wheel bolts. Use wheel impact socket #19.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 Nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – VOLVO C70 II Convertible. Check the brake fluid level in the reservoir and top up if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
VOLVO C70 II Convertible – Without starting the engine, press the brake pedal several times until it feels firm.
Step 26

Close the hood.

Replacement: brake pads – VOLVO C70 II Convertible. Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VOLVO C70 II Convertible (542) model

Volvo C70 Convertible tyre size

How to change front brake discs on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
1.95 MB
How to change rear brake discs on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
1.83 MB
How to change front brake pads on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
1.56 MB
How to change front windshield wipers on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
604.16 KB
How to change front anti roll bar links on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
1.2 MB
How to change engine oil and filter on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
2.3 MB

How to change front brake pads on VOLVO C70 II Convertible (542) – replacement guide

Free download PDF
1.56 MB
How to change front brake pads on VOLVO C70 I Coupe (872) – replacement guide

Free download PDF
1.55 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.25 MB
How to change rear brake pads on Volvo XC90 1 – replacement guide

Free download PDF
1.83 MB
How to change front brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.36 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 5 possible reasons your car is shaking or vibrating

6K views

Published on: 14/02/2025
TOP 5 mistakes during DIY oil change | AUTODOC tips

36K views

Published on: 17/06/2021
#DIY Tips for Fixing Your Car's Air Conditioning Issues | Don't Wait for Costly Repairs!

7K views

Published on: 05/08/2021
The Fast and Easy Way to Fix a Broken Wheel Stud | AUTODOC tips

9K views

Published on: 08/12/2020