How to carry out replacement: Brake Discs 2.0 TDI Seat Exeo st
Disclaimer
Change Seat Exeo st 2.0 TFSI Brake Discs yourself – manuals and video tutorials

How to change rear brake discs on SEAT Exeo ST (3R5) – replacement guide

downloads: 2
Views: 42
Download your free tutorial and fix SEAT Exeo ST (3R5) 1.8 T problems yourself Download for free 1.88 MB Brake Discs for Seat Exeo st Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your SEAT EXEO
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
SEAT Exeo ST (3R5) 1.6, SEAT Exeo ST (3R5) 2.0 TFSI, SEAT Exeo ST (3R5) 2.0 TDI, SEAT Exeo ST (3R5) 2.0 TDI, SEAT Exeo ST (3R5) 2.0 TDI, SEAT Exeo ST (3R5) 1.8 TSI, SEAT Exeo ST (3R5) 1.8 TSI, SEAT Exeo ST (3R5) 2.0 TFSI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Exeo ST (3R5) and other SEAT models
Alternative products
How to change Brake disc on Seat Exeo st 2.0 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – SEAT EXEO ST (3R5). Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 13
Combination spanner #13
Combination spanner #15
HEX bit no.H8.
Wheel impact socket #17
Brake caliper wind back tool
Torque wrench
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – SEAT EXEO ST (3R5). AUTODOC recommends:
  • Replace the brake disks on the car SEAT EXEO ST (3R5) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – SEAT EXEO ST (3R5). Take the following steps:
  1. Step 1
    Open the bonnet.
    Step 2
    How to change Brake Discs on Seat Exeo st 2009 - free PDF and video manuals
    Unscrew the brake fluid reservoir cap.
  2. Step 3
    How to replace SEAT Exeo ST (3R5) 2.0 TDI 2010 Brake Discs - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 4
    Seat Exeo st 1.8 TSI 2011 Brake Discs replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  4. Step 5
    Raise the rear of the car and secure on supports.
    Step 6
    Changing Brake Discs on SEAT Exeo ST (3R5) 2.0 TFSI 2012 by yourself
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. SEAT EXEO ST (3R5)
  5. Step 7
    How to remove SEAT EXEO 1.6 2013 Brake Discs - online easy-to-follow instructions
    Remove the wheel.
  6. Step 8
    How to replace Brake Discs on SEAT Exeo ST (3R5) 2014: download PDF manuals and video instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on Seat Exeo st 1.8 TSI 2015 - download illustrated guide
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
  8. Step 10
    Need to know how to renew Brake Discs on SEAT EXEO 2016? This free workshop manual will help you to do it yourself
    Remove the brake caliper. Use a crowbar.
    Replacement: brake discs – SEAT EXEO ST (3R5). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  9. Step 11
    Changing of Brake Discs on Seat Exeo st 2017 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads. Use a crowbar.
  10. Step 12
    SEAT EXEO 2.0 TFSI Brake Discs replacement: online guides and video tutorials
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  11. Step 13
    Replacing Brake Discs on Seat Exeo st 2019 2.0 TDI by yourself
    Unscrew the caliper bracket fastening. Use HEX No.H8.
  12. Step 14
    Exeo ST (3R5) 1.6 2020 Brake Discs DIY replacement workshop manual
    Remove the caliper bracket.
  13. Step 15
    How to change Brake Discs on SEAT Exeo ST (3R5) 2021 - tips and tricks
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
  14. Step 16
    Step-by-step recommendations for DIY replacement Seat Exeo st 2022 1.6 Brake Discs
    Remove the retaining ring. Use a crowbar.
  15. Step 17
    DIY replacement of Brake Discs on SEAT Exeo ST (3R5) 1.8 T 2023 is not an issue anymore with our step-by-step tutorial
    Remove the brake disc.
  16. Step 18
    How to change Brake Discs on Seat Exeo st 2009 - free PDF and video manuals
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  17. Step 19
    How to replace SEAT Exeo ST (3R5) 2.0 TDI 2010 Brake Discs - step-by-step manuals and video guides
    Install the brake disc. Install the retaining ring.
  18. Step 20
    Seat Exeo st 1.8 TSI 2011 Brake Discs replacement: free workshop manuals
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    Replacement: brake discs – SEAT EXEO ST (3R5). Tip:
    After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Exeo ST (3R5) model

Seat Exeo st tyre size

Popular maintenance tutorials for Seat Exeo st

More manuals for Seat Exeo st

Complete guides for changing the Brake rotors on different SEAT EXEO models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SEAT Exeo ST (3R5) Brake Discs replacement - online guide
Tips & tricks for your SEAT Exeo ST (3R5)
View more
  • How to change Brake rotors on SEAT Exeo ST (3R5) 1.8 T - replacement tricks
    How to prevent car windows from fogging up | AUTODOC tips
    13K views
    Published on: 04/02/2021
  • Changing Brake disc Seat Exeo st 2.0 TDI - Replacement Tips
    Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC
    5K views
    Published on: 03/12/2020
  • Maintenance Hacks - SEAT Exeo ST (3R5) 1.8 TSI Rotors replacement guide
    5 Essential Tips to Prepare Your Car for Winter | AUTODOC tips
    6K views
    Published on: 05/02/2024
  • Replace Disc brakes on Seat Exeo st - free video tips
    TOP 5 mistakes when replacing shock absorbers | AUTODOC tips
    14K views
    Published on: 15/06/2023

Most commonly replaced car parts on SEAT EXEO

Professional manuals for the most common SEAT models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SEAT Exeo ST (3R5) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME