How to carry out replacement: Brake Discs 2.0 TDI Seat Exeo Saloon
Disclaimer
Change Seat Exeo Saloon 1.8 TSI Brake Discs yourself – manuals and video tutorials

How to change front brake discs on SEAT Exeo Saloon (3R2) – replacement guide

downloads: 1
Views: 20
Download your free tutorial and fix SEAT Exeo Saloon (3R2) 2.0 TFSI problems yourself Download for free 2.03 MB Brake Discs for Seat Exeo Saloon Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your SEAT EXEO
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
SEAT Exeo Saloon (3R2) 1.8 TSI, SEAT Exeo Saloon (3R2) 2.0 TDI, SEAT Exeo Saloon (3R2) 2.0 TDI, SEAT Exeo Saloon (3R2) 1.6 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Exeo Saloon (3R2) and other SEAT models
Alternative products
How to change Brake disc on Seat Exeo Saloon 2.0 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – SEAT EXEO (3R2). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
Drive socket # 17
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Tap wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
AUTODOC recommends:
  • Replace the brake disks on the car SEAT EXEO (3R2) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – SEAT EXEO (3R2) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the hood. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Discs on Seat Exeo Saloon 2008 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    How to replace SEAT Exeo Saloon (3R2) 2.0 TDI 2009 Brake Discs - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. SEAT EXEO (3R2)
  3. Step 6
    Seat Exeo Saloon 1.8 T 2010 Brake Discs replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Discs on SEAT Exeo Saloon (3R2) 1.8 TSI 2011 by yourself
    Spread the brake pads. Use a crowbar.
  5. Step 8
    How to remove SEAT EXEO 1.6 2012 Brake Discs - online easy-to-follow instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  6. Step 9
    How to replace Brake Discs on SEAT Exeo Saloon (3R2) 2013: download PDF manuals and video instructions
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  7. Step 10
    How hard is it to do yourself: Brake Discs replacement on Seat Exeo Saloon 1.8 T 2014 - download illustrated guide
    Disconnect the brake pad wear sensor plug.
  8. Step 11
    Need to know how to renew Brake Discs on SEAT EXEO 2015? This free workshop manual will help you to do it yourself
    Disconnect the brake pads wear sensor. Use a crowbar.
    Please note!
    Some cars are not equipped with the brake pad wear sensor.
  9. Step 12
    Changing of Brake Discs on Seat Exeo Saloon 2016 won't be an issue if you follow this illustrated step-by-step guide
    Detach the brake caliper retaining spring. Use a crowbar.
  10. Step 13
    SEAT EXEO 1.8 TSI Brake Discs replacement: online guides and video tutorials
    Remove the brake caliper.
    Replacement: brake discs – SEAT EXEO (3R2). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 14
    Replacing Brake Discs on Seat Exeo Saloon 2018 2.0 TDI by yourself
    Remove the brake pads.
  12. Step 15
    Exeo Saloon (3R2) 1.6 2019 Brake Discs DIY replacement workshop manual
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use WD-40 spray.
  13. Step 16
    How to change Brake Discs on SEAT Exeo Saloon (3R2) 2020 - tips and tricks
    Unscrew the caliper bracket fastening. Use a drive socket #17. Use a tap wrench. Use a ratchet wrench.
  14. Step 17
    Step-by-step recommendations for DIY replacement Seat Exeo Saloon 2021 1.6 Brake Discs
    Remove the caliper bracket.
  15. Step 18
    DIY replacement of Brake Discs on SEAT Exeo Saloon (3R2) 2.0 TFSI 2022 is not an issue anymore with our step-by-step tutorial
    Remove the brake disc.
  16. Step 19
    How to change Brake Discs on Seat Exeo Saloon 2008 - free PDF and video manuals
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  17. Step 20
    How to replace SEAT Exeo Saloon (3R2) 2.0 TDI 2009 Brake Discs - step-by-step manuals and video guides
    Install the brake disc.
  18. Step 21
    Seat Exeo Saloon 1.8 T 2010 Brake Discs replacement: free workshop manuals
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – SEAT EXEO (3R2). After applying the spray, wait a few minutes.
  19. Step 22
    Changing Brake Discs on SEAT Exeo Saloon (3R2) 1.8 TSI 2011 by yourself
    Install the brake caliper bracket.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Exeo Saloon (3R2) model

Seat Exeo Saloon tyre size

Popular maintenance tutorials for Seat Exeo Saloon

More manuals for Seat Exeo Saloon

Complete guides for changing the Brake rotors on different SEAT EXEO models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SEAT Exeo Saloon (3R2) Brake Discs replacement - online guide
Tips & tricks for your SEAT Exeo Saloon (3R2)
View more
  • How to change Brake rotors on SEAT Exeo Saloon (3R2) 2.0 TFSI - replacement tricks
    Fuse Replacement Made Simple: Step-by-Step Guide | AUTODOC
    2K views
    Published on: 15/08/2020
  • Changing Brake disc Seat Exeo Saloon 2.0 TDI - Replacement Tips
    How to fix your car with AUTODOC CLUB
    17K views
    Published on: 30/11/2021
  • Maintenance Hacks - SEAT Exeo Saloon (3R2) 1.8 T Rotors replacement guide
    Easy Steps to Paint Brake Calipers Without Special Skills or High Costs
    10K views
    Published on: 08/04/2021
  • Replace Disc brakes on Seat Exeo Saloon - free video tips
    Top Automatic Transmission Blunders You Must Dodge | AUTODOC Insights
    7K views
    Published on: 26/01/2021

Most commonly replaced car parts on SEAT EXEO

Professional manuals for the most common SEAT models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SEAT Exeo Saloon (3R2) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME