How to carry out replacement: Brake Discs 1.8 T Audi TT 8N Roadster
Disclaimer
Change Audi TT 8N Roadster 3.2 VR6 quattro Brake Discs yourself – manuals and video tutorials

How to change rear brake discs on AUDI TT Roadster (8N9) – replacement guide

downloads: 3
Views: 25
Download your free tutorial and fix AUDI TT Roadster (8N9) 1.8 T quattro problems yourself Download for free 1.39 MB Brake Discs for Audi TT 8N Roadster Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your AUDI TT
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
AUDI TT Roadster (8N9) 1.8 T quattro, AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for TT Roadster (8N9) and other AUDI models
Alternative products
How to change Brake disc on Audi TT 8N Roadster 1.8 T – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – AUDI TT Roadster (8N9). Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Combination spanner #13
Combination spanner #15
Drive socket # 13
Torx bit T30
Torque wrench
Wheel impact socket #17
Rubber mallet
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – AUDI TT Roadster (8N9). Professionals recommend:
  • Replace the brake disks on the car AUDI TT Roadster (8N9) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – AUDI TT Roadster (8N9). Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on Audi TT 8N Roadster 1999 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace AUDI TT Roadster (8N9) 1.8 T 2000 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    Audi TT 8N Roadster 1.8 T quattro 2001 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake discs – AUDI TT Roadster (8N9). AUTODOC experts recommend:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Discs on AUDI TT Roadster (8N9) 1.8 T 2002 by yourself
    Remove the wheel.
  5. Step 7
    Disconnect the ABS sensor electric socket. Disconnect the brake pad wear sensor plug. Remove the ABS sensor connector. Remove the connector of the brake pad wear sensor.
    Please note!
    Some cars are not equipped with the brake pad wear sensor.
    Step 8
    Spread the brake pads. Use a crowbar.
    Step 9
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
    Step 10
    How to remove AUDI TT 1.8 T quattro 2003 Brake Discs - online easy-to-follow instructions
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
  6. Step 11
    How to replace Brake Discs on AUDI TT Roadster (8N9) 2004: download PDF manuals and video instructions
    Remove the brake caliper.
    AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  7. Step 12
    How hard is it to do yourself: Brake Discs replacement on Audi TT 8N Roadster 1.8 T 2005 - download illustrated guide
    Press in the brake caliper piston. Use brake caliper wind back tool.
  8. Step 13
    Need to know how to renew Brake Discs on AUDI TT 2006? This free workshop manual will help you to do it yourself
    Unscrew the brake disc mounting bolts and remove it. Use Torx T30.
    Replacement: brake discs – AUDI TT Roadster (8N9). Tip:
    If necessary, use a rubber mallet.
  9. Step 14
    Changing of Brake Discs on Audi TT 8N Roadster 1999 won't be an issue if you follow this illustrated step-by-step guide
    Clean the hub. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – AUDI TT Roadster (8N9). After applying the spray, wait a few minutes.
  10. Step 15
    AUDI TT 3.2 VR6 quattro Brake Discs replacement: online guides and video tutorials
    Treat the contacting surface. Use copper grease.
  11. Step 16
    Remove anti-corrosion grease from the new brake disk. Use a brake cleaner.
    Replacement: brake discs – AUDI TT Roadster (8N9). Tip from AUTODOC experts:
    After applying the spray, wait a few minutes.
    Step 17
    Replacing Brake Discs on Audi TT 8N Roadster 2001 1.8 T by yourself
    Install the brake disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI TT Roadster (8N9) model

Audi TT 8N Roadster tyre size

Popular maintenance tutorials for Audi TT 8N Roadster

More manuals for Audi TT 8N Roadster

Complete guides for changing the Brake rotors on different AUDI TT models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI TT Roadster (8N9) Brake Discs replacement - online guide
Tips & tricks for your AUDI TT Roadster (8N9)
View more
  • How to change Brake rotors on AUDI TT Roadster (8N9) 3.2 VR6 quattro - replacement tricks
    How to remove rust | AUTODOC tips
    27K views
    Published on: 16/09/2021
  • Changing Brake disc Audi TT 8N Roadster 1.8 T - Replacement Tips
    5 possible reasons why your car heater isn't working
    6K views
    Published on: 21/11/2024
  • Maintenance Hacks - AUDI TT Roadster (8N9) 1.8 T quattro Rotors replacement guide
    How to repair a bumper yourself | AUTODOC tips
    16K views
    Published on: 01/06/2023
  • Replace Disc brakes on Audi TT 8N Roadster - free video tips
    5 causes of turbocharger failure and how to avoid them
    13K views
    Published on: 04/04/2024

Most commonly replaced car parts on AUDI TT

Professional manuals for the most common AUDI models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI TT Roadster (8N9) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME