When to replace the Brake Discs on your AUDI TT
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T quattro, AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T, AUDI TT Roadster (8N9) 1.8 T quattro, AUDI TT Roadster (8N9) 1.8 T quattro, AUDI TT Roadster (8N9) 1.8 T View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Tools
Replacement: brake discs – AUDI TT Roadster (8N9). Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Ceramic grease
Torque wrench
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Crow bar
Tap wrench
Impact screwdriver
Hammer
Phillips screwdriver
Wheel chock
AUTODOC recommends:
  • Replace the brake disks on the car AUDI TT Roadster (8N9) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – AUDI TT Roadster (8N9). Recommended sequence of steps:
  1. Step 1
    Open the bonnet.
    Step 2
    Unscrew the brake fluid reservoir cap.
    Step 3
    Secure the wheels with chocks.
    Step 4
    How to change Brake Discs on Audi TT 8N Roadster 1999 - free PDF and video manuals
    Loosen the wheel bolts. Use wheel impact socket #17. Use a tap wrench.
  2. Step 5
    Raise the car.
    Replacement: brake discs – AUDI TT Roadster (8N9). Tip from AUTODOC:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 6
    How to replace AUDI TT Roadster (8N9) 1.8 T 2000 Brake Discs - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  3. Step 7
    Audi TT 8N Roadster 1.8 T quattro 2001 Brake Discs replacement: free workshop manuals
    Remove the wheel.
  4. Step 8
    Changing Brake Discs on AUDI TT Roadster (8N9) 1.8 T 2002 by yourself
    Remove the caps from the brake caliper guide pin boots. Use a crowbar.
  5. Step 9
    How to remove AUDI TT 1.8 T quattro 2003 Brake Discs - online easy-to-follow instructions
    Unscrew the brake caliper fasteners. Use HEX No.H7. Use a ratchet wrench.
  6. Step 10
    How to replace Brake Discs on AUDI TT Roadster (8N9) 2004: download PDF manuals and video instructions
    Spread the brake pads. Use a crowbar.
  7. Step 11
    How hard is it to do yourself: Brake Discs replacement on Audi TT 8N Roadster 1.8 T 2005 - download illustrated guide
    Remove the brake caliper.
    Replacement: brake discs – AUDI TT Roadster (8N9). AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  8. Step 12
    Need to know how to renew Brake Discs on AUDI TT 2006? This free workshop manual will help you to do it yourself
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  9. Step 13
    Changing of Brake Discs on Audi TT 8N Roadster 1999 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake disc fasteners. Use an impact screwdriver. Use a hammer.
  10. Step 14
    AUDI TT 3.2 VR6 quattro Brake Discs replacement: online guides and video tutorials
    Remove the fastening bolt.
  11. Step 15
    Replacing Brake Discs on Audi TT 8N Roadster 2001 1.8 T by yourself
    Remove the brake disc.
  12. Step 16
    TT Roadster (8N9) 1.8 T quattro 2002 Brake Discs DIY replacement workshop manual
    Clean the brake caliper bracket of dirt and dust. Use a wire brush. Use a brake cleaner.
  13. Step 17
    How to change Brake Discs on AUDI TT Roadster (8N9) 2003 - tips and tricks
    Clean the wheel hub. Use a wire brush. Use a brake cleaner.
  14. Step 18
    Step-by-step recommendations for DIY replacement Audi TT 8N Roadster 2004 1.8 T quattro Brake Discs
    Treat the contacting surface. Use ceramic grease.
  15. Step 19
    DIY replacement of Brake Discs on AUDI TT Roadster (8N9) 3.2 VR6 quattro 2005 is not an issue anymore with our step-by-step tutorial
    Install a new brake disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the AUDI TT Roadster (8N9) model.

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
AUDI TT Roadster (8N9) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY AUDI TT Roadster (8N9) Brake Discs replacement - online guide
Tips & tricks for your AUDI TT Roadster (8N9)
View more
  • How to change Brake rotors on AUDI TT Roadster (8N9) 3.2 VR6 quattro - replacement tricks
    TOP 4 car cleaning products | AUTODOC tips
  • Changing Brake disc Audi TT 8N Roadster 1.8 T - Replacement Tips
    How to restore a damaged thread | AUTODOC tips
  • Maintenance Hacks - AUDI TT Roadster (8N9) 1.8 T quattro Brake disc kit replacement guide
    5 tools that make car repair incredibly simple | AUTODOC tips
  • Replace Disc brake set on Audi TT 8N Roadster - free video tips
    What to do if the belt squeals | AUTODOC tips

Professional manuals for the most common AUDI models