How to carry out replacement: Gearbox Oil and Transmission Oil 1.2 Chevrolet Aveo T250
Disclaimer
Change Chevrolet Aveo T250 1.6 Gearbox Oil and Transmission Oil yourself – manuals and video tutorials

How to change manual gearbox oil on CHEVROLET Aveo / Kalos Hatchback (T250, T255) – replacement guide

downloads: 47
Views: 1237
Download your free tutorial and fix CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.4 problems yourself Download for free 1.22 MB Gearbox Oil and Transmission Oil for Chevrolet Aveo T250 Shop now
Leave a comment Open in a new tab
When to replace the Gearbox Oil and Transmission Oil on your CHEVROLET AVEO
Recommended replacement interval for the part category Automatic transmission fluid : 50000 km
Important!
This replacement procedure can be used for:
CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.6 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Gearbox Oil and Transmission Oil for Aveo / Kalos Hatchback (T250, T255) and other CHEVROLET models
How to change Automatic transmission fluid on Chevrolet Aveo T250 1.2 – step-by-step instructions for straightforward car repair Automatic transmission fluid
How to change Manual Transmission Oil on Chevrolet Aveo T250 1.2 – step-by-step instructions for straightforward car repair Manual Transmission Oil
How to change Automatic transmission fluid on Aveo / Kalos Hatchback (T250, T255) – tips for proper car maintenance
Automatic transmission fluid for Aveo / Kalos Hatchback (T250, T255) Petrol (110 hp)
Tools
Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). List of the tools you'll need:
Wire brush
All-purpose cleaning spray
HEX bit No.H17.
Drive socket # 12
Phillips screwdriver
Torque wrench
Funnel
Oil drain pan
Fender cover
Buy tools
Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). AUTODOC recommends:
  • All work should be done with the engine stopped.
Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). Recommended sequence of steps:
  1. Step 1
    Open the hood.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    Lift the car using a jack or place it over an inspection pit.
    Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). Tip:
    The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
    Step 4
    How to change Gearbox Oil and Transmission Oil on Chevrolet Aveo T250 2006 - free PDF and video manuals
    Unscrew the fasteners of the lower sound insulation. Use a drive socket #12. Use a Phillips screwdriver.
  2. Step 5
    How to replace CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.2 2007 Gearbox Oil and Transmission Oil - step-by-step manuals and video guides
    Remove the lower sound insulation.
  3. Step 6
    Chevrolet Aveo T250 1.2 LPG 2008 Gearbox Oil and Transmission Oil replacement: free workshop manuals
    Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
    AUTODOC recommends:
    Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). After applying the spray, wait a few minutes.
  4. Step 7
    Changing Gearbox Oil and Transmission Oil on CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.6 2009 by yourself
    Put a waste oil container with at least 2 l capacity under the drainage hole.
  5. Step 8
    How to remove CHEVROLET AVEO 1.4 16V 2010 Gearbox Oil and Transmission Oil - online easy-to-follow instructions
    Unscrew the drain plug. Use HEX No.H17.
  6. Step 9
    How to replace Gearbox Oil and Transmission Oil on CHEVROLET Aveo / Kalos Hatchback (T250, T255) 2011: download PDF manuals and video instructions
    Drain the used oil.
    Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). AUTODOC experts recommend:
    Caution! The oil may be hot.
  7. Step 10
    How hard is it to do yourself: Gearbox Oil and Transmission Oil replacement on Chevrolet Aveo T250 1.2 LPG 2012 - download illustrated guide
    Clean the area around the gearbox housing filler hole. Use a wire brush. Use all-purpose cleaning spray.
    Replacement: manual gearbox oil – CHEVROLET AVEO Hatchback (T250, T255). Tip from AUTODOC:
    After applying the spray, wait a few minutes.
  8. Step 11
    Need to know how to renew Gearbox Oil and Transmission Oil on CHEVROLET AVEO 2013? This free workshop manual will help you to do it yourself
    Unscrew the filler plug of the gearbox housing. Use HEX No.H17.
Comments – 1
  • @user_1392464
    07.02.2023 20:16
    Member
    Whant to change gearbox oil on cheve aveo 1.6 LS 2010 Outomatic and what oil must I use
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the CHEVROLET Aveo / Kalos Hatchback (T250, T255) model.

Chevrolet Aveo T250 tyre size

Popular maintenance tutorials for Chevrolet Aveo T250

More manuals for Chevrolet Aveo T250

Complete guides for changing the Gear oil on different CHEVROLET AVEO models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
CHEVROLET Aveo / Kalos Hatchback (T250, T255) Gearbox Oil and Transmission Oil replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY CHEVROLET Aveo / Kalos Hatchback (T250, T255) Gearbox Oil and Transmission Oil replacement - online guide
Tips & tricks for your CHEVROLET Aveo / Kalos Hatchback (T250, T255)
View more
  • How to change Gear oil on CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.4 - replacement tricks
    How to choose the right engine oil for your car | AUTODOC
    8K views
    Published on: 01/07/2020
  • Changing Transmission fluid Chevrolet Aveo T250 1.2 - Replacement Tips
    What causes engine misfire? | AUTODOC
    5K views
    Published on: 10/07/2020
  • Maintenance Hacks - CHEVROLET Aveo / Kalos Hatchback (T250, T255) 1.2 LPG Gearbox oil replacement guide
    How do EGR valves work? | AUTODOC
    18K views
    Published on: 18/07/2020
  • Replace Manual transmission oil on Chevrolet Aveo T250 - free video tips
    DIY starter repair | AUTODOC tips
    41K views
    Published on: 31/08/2023

Most commonly replaced car parts on CHEVROLET AVEO

Professional manuals for the most common CHEVROLET models