Recommended replacement interval for the part category Glow plug : 30000 km

Important!

This replacement procedure can be used for:
VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 TDI 4motion, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 BiTDI 4motion, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 BiTDI, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 TDI 4motion, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 TDI, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 TDI, VW Amarok Platform / Chassis (S1B, S6B, S7B) 2.0 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Glow Plugs for Amarok Platform / Chassis (S1B, S6B, S7B) and other VW models

Glow plug

        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (122 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (140 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (163 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (163 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (180 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (180 hp)
      
        Glow plug for Amarok Platform / Chassis (S1B, S6B, S7B) Diesel (140 hp)

Replacement: glow plugs – VW AMAROK Platform/Chassis (S1B). Tools you might need:

                        WD-40 spray
                      
                        Electronic spray
                      
                        High-temperature ceramic grease
                      
                        Torque wrench
                      
                        Spark plug socket # 10
                      
                        Torx bit T27
                      
                        Ratchet wrench
                      
                        Flat screwdriver
                      
                        Needle nose pliers
                      
                        Fender cover

Buy tools

Replacement: glow plugs – VW AMAROK Platform/Chassis (S1B). AUTODOC experts recommend:

The replacement procedure is identical for all glow plugs.
Wear gloves to protect your hands from hot surfaces.
Replacement: glow plugs – VW AMAROK Platform/Chassis (S1B). Recommended sequence of steps:

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Before getting down to work, start the engine and let it warm up to operating temperature.

Step 4

Shut off the engine.

Step 5

Unscrew the bracket for the engine pipes. Use Torx T27. Use a ratchet wrench.
Step 6

Detach the engine wiring harness. Use a flat screwdriver.
Step 7

Detach the engine wiring harness connectors. Use a flat screwdriver.
Step 8

Detach the glow plug wiring connectors. Use needle nose pliers.
Step 9

Clean dirt, dust and debris from inside the spark plug wells.
Step 10

Treat the glow plugs. Use WD-40 spray.
Step 11

Unscrew the glow plugs. Use the spark plug socket #10. Use a torque wrench.
Step 12

Clean dirt, dust and debris from inside the spark plug wells.
Step 13

Remove the glow plugs. Use the spark plug socket #10. Use needle nose pliers.
Step 14

Treat the glow plugs. Use high-temperature ceramic grease.

Please note!
Do not touch the heating element as fingerprints may cause malfunction.
Step 15

Install new glow plugs to their mounting seats. Use needle nose pliers.
Step 16

Tighten the glow plugs. Use the spark plug socket #10. Use a torque wrench. Tighten it to 18 nm torque.

Replacement: glow plugs – VW AMAROK Platform/Chassis (S1B). Tip from AUTODOC experts:
Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection. Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.
Step 17

Attach the glow plug wiring connectors.
Step 18

Treat the engine wiring harness connectors. Use dielectric grease.
Step 19

Attach the engine wiring harness connectors.
Step 20

Attach the engine wiring harness.

Step 21

Screw in the bracket for the engine pipes. Use Torx T27. Use a torque wrench. Tighten it to 7 nm torque.

Step 22

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 23

Shut off the engine.

Step 24

Remove the fender protection cover.

Step 25

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Amarok Platform / Chassis (S1B, S6B, S7B) model.

Browse tyres

How to change front windshield wipers on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
1.56 MB
How to change engine oil and filter on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
1.68 MB
How to change fuel filter on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
952.32 KB
How to change pollen filter on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
829.44 KB
How to change headlight bulb on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
1.48 MB
How to change front ABS sensor on VW Amarok Platform / Chassis (S1B, S6B, S7B) – replacement guide

Free download PDF
1.28 MB

How to change glow plugs on VW Amarok Pickup (2HA, 2HB, S1B, S6B, S7A, S7B) – replacement guide

Free download PDF
1.22 MB
How to change glow plugs on a car – replacement tutorial

Universal

Free download PDF
1.62 MB
How to change glow plugs on VW Passat B7 saloon – replacement guide

Free download PDF
1.57 MB
How to change glow plugs on VW Caddy 3 van – replacement guide

Free download PDF
1.09 MB
How to change glow plugs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) – replacement guide

Free download PDF
1.2 MB
How to change glow plugs on VW Crafter Van (SY_, SX_) – replacement guide

Free download PDF
1.2 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to polish an old engine valve cover to a shiny finish | AUTODOC Tips

8K views

Published on: 30/11/2023
TOP 5 mistakes during DIY oil change | AUTODOC tips

34K views

Published on: 17/06/2021
Coolant comparison test | AUTODOC

4K views

Published on: 13/10/2022
4 reasons why your CHECK ENGINE light is on | AUTODOC tips

6K views

Published on: 30/03/2022