Recommended replacement interval for the part category Fuel filter : 90000 km

Important!

This replacement procedure can be used for:
VW Passat Alltrack (365) 2.0 TDI 4motion, VW Passat Alltrack (365) 2.0 TDI, VW Passat Alltrack (365) 2.0 TDI 4motion, VW Passat Alltrack (365) 2.0 TDI 4motion … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Passat Alltrack (365) and other VW models

Fuel filter

        Fuel filter for Passat B7 Alltrack (365) Diesel (140 hp)
      
        Fuel filter for Passat B7 Alltrack (365) Diesel (140 hp)
      
        Fuel filter for Passat B7 Alltrack (365) Diesel (170 hp)
      
        Fuel filter for Passat B7 Alltrack (365) Diesel (177 hp)

Replacement: fuel filter – VW PASSAT ALLTRACK (365). Tools you might need:

                        All-purpose cleaning spray
                      
                        Torque wrench
                      
                        Torx bit T15
                      
                        Ratchet wrench
                      
                        Flat screwdriver
                      
                        Hand-operated fluid syringe

                        Fender cover

Buy tools

Replacement: fuel filter – VW PASSAT ALLTRACK (365). Tip from AUTODOC:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VW PASSAT ALLTRACK (365). Use the following procedure:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 4

Unscrew the fasteners of the fuel filter housing cover. Use Torx T15. Use a ratchet wrench.
Step 5

Remove the fuel filter housing cover. Use a flat screwdriver.
Step 6

Remove the fuel filter. Use a flat screwdriver.

Replacement: fuel filter – VW PASSAT ALLTRACK (365). AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Put the old filter cartridge in the container.
Step 8

Pump the fuel out of the fuel filter housing. Use a hand-operated fluid syringe.
Step 9

Clean the fuel filter housing and the cover.
Step 10

Install a new fuel filter.

Replacement: fuel filter – VW PASSAT ALLTRACK (365). Tip:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – VW PASSAT ALLTRACK (365).
Step 11

Install and tighten the cap of the fuel filter housing. Use Torx T15. Use a ratchet wrench.
Step 12

Tighten the fasteners of the fuel filter housing cover. Use Torx T15. Use a torque wrench. Tighten it to 6 Nm torque.
Step 13

Connect the scan and service tool and set the fuel system to operating mode. This is necessary so that the fuel system fills completely with fuel.
Step 14

Switch on the ignition.

Step 15

Disconnect the scan and service tool.

Step 16

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 17

Shut off the engine.

Step 18

Remove the fender protection cover.

Step 19

Close the hood.

Replacement: fuel filter – VW PASSAT ALLTRACK (365). Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Passat B7 Alltrack (365) model.

Browse tyres

How to change air filter on VW Passat B7 Alltrack (365) – replacement guide

Free download PDF
1.65 MB
How to change engine oil and filter on VW Passat Alltrack (365) – replacement guide

Free download PDF
1.7 MB
How to change pollen filter on VW Passat B7 Alltrack (365) – replacement guide

Free download PDF
1.61 MB
How to change front brake pads on VW Passat Alltrack (365) – replacement guide

Free download PDF
1.63 MB
How to change rear brake pads on VW Passat B7 Alltrack (365) – replacement guide

Free download PDF
2.42 MB
How to change front brake discs on VW Passat Alltrack (365) – replacement guide

Free download PDF
2.18 MB

How to change fuel filter on VW Passat B6 Saloon (3C2) – replacement guide

Free download PDF
1.63 MB
How to change fuel filter on VW Passat CC (357) – replacement guide

Free download PDF
1.78 MB
How to change fuel filter on VW Passat B7 Variant (365) – replacement guide

Free download PDF
1.78 MB
How to change fuel filter on VW Passat 3C B6 Variant – replacement guide

Free download PDF
1.36 MB
How to change fuel filter on VW Passat B7 saloon – replacement guide

Free download PDF
2.02 MB
How to change fuel filter on VW Passat B5 Variant diesel – replacement guide

Free download PDF
1.49 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023
How to remove scratches from a car | AUTODOC tips

7K views

Published on: 12/05/2022
Top 6 products for enhancing your car | AUTODOC tips

3K views

Published on: 18/11/2021
DIY starter repair | AUTODOC tips

40K views

Published on: 31/08/2023