Recommended replacement interval for the part category Fuel filter : 30000 km

Important!

This replacement procedure can be used for:
VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.4, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Fox Hatchback (5Z1, 5Z3, 5Z4) and other VW models

Alternative products

Fuel filter

Replacement: fuel filter – VW FOX (5Z1, 5Z3). Tools you'll need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Phillips screwdriver
                    
                      Flat Screwdriver
                    
                      Fluid container

Buy tools

Replacement: fuel filter – VW FOX (5Z1, 5Z3). AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VW FOX (5Z1, 5Z3). Recommended sequence of steps:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.

Step 4

Prepare a container for fluids.
Step 5

Clean the fuel filter. Use a wire brush. Use all-purpose cleaning spray.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver.

Replacement: fuel filter – VW FOX (5Z1, 5Z3). Professionals recommend:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Loosen the fuel filter mounting. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Put the old filter cartridge in the container.

Step 10

Install a new fuel filter.

Replacement: fuel filter – VW FOX (5Z1, 5Z3). AUTODOC recommends:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – VW FOX (5Z1, 5Z3).
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 12

Tighten the fuel filter fasteners. Use a Phillips screwdriver.
Step 13

Take the fluid container away from under the fuel filter.
Step 14

Lower the car.
Step 15

Tighten the fuel filler cap.

Step 16

Close the fuel door.

Replacement: fuel filter – VW FOX (5Z1, 5Z3). AUTODOC experts recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 17

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 18

Shut off the engine.

Replacement: fuel filter – VW FOX (5Z1, 5Z3). Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Fox Hatchback (5Z1, 5Z3, 5Z4) model

VW Fox 5z1 tyre size

How to change pollen filter on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.41 MB
How to change air filter on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1013.76 KB
How to change engine oil and filter on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.41 MB
How to change front brake pads on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.35 MB
How to change front brake discs on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.45 MB
How to change rear wheel bearing on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.37 MB

How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on VW Polo 9N – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Golf 5 – replacement guide

Free download PDF
1.87 MB
How to change fuel filter on VW Passat B7 saloon – replacement guide

Free download PDF
2.02 MB
How to change fuel filter on VW Touran 1T1 1T2 – replacement guide

Free download PDF
1.18 MB
How to change fuel filter on VW Golf 4 – replacement guide

Free download PDF
1.8 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

5 causes of turbocharger failure and how to avoid them

13K views

Published on: 04/04/2024
How to make an injector test bench yourself

5K views

Published on: 30/01/2025
DIY manual gearbox restoration | Drivetrain restoration – Part 3

13K views

Published on: 14/11/2024
5 Essential Tips for beginner drivers: Avoid Common Mistakes

4K views

Published on: 31/01/2023