Recommended replacement interval for the part category Fuel filter : 30000 km

Important!

This replacement procedure can be used for:
RENAULT MASTER II Platform/Chassis (ED/HD/UD) 2.5 dCi, RENAULT MASTER II Platform/Chassis (ED/HD/UD) 2.2 dCI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Fuel filter

Replacement: fuel filter – RENAULT MASTER II Platform/Chassis (ED/HD/UD). Tools you need:

                      All-purpose cleaning spray
                    
                      Electronic spray
                    
                      Torque wrench
                    
                      T30 Torx bit
                    
                      Ratchet screwdriver
                    
                      Fuel line pliers
                    
                      Fluid drain pan
                    
                      Fender cover

Buy tools

Replacement: fuel filter – RENAULT MASTER II Platform/Chassis (ED/HD/UD). Professionals recommend:

Ensure adequate ventilation of the workplace. Fuel vapours are poisonous.
To avoid fire, wait until the engine has cooled down completely before beginning work. Keep open flames or sources of sparks away from the area.
Relieve the fuel system pressure using the method specified by your car manufacturer, to prevent fuel from spraying out.
All the work should be carried out with the ignition switched off.

Replacement: fuel filter – RENAULT MASTER II Platform/Chassis (ED/HD/UD). Use the following procedure:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to avoid damaging the paintwork and plastic parts of the car.

Step 3

Prepare a fluid drain pan.

Step 4

Clean all filter connections. Use an all-purpose cleaning spray.
Step 5

Detach the electrical connector of the fuel filter.
Step 6

Disconnect the fuel lines from the fuel filter. Plug the fuel lines immediately after disconnecting them to prevent spills and contamination. Use the fuel line pliers.
Step 7

Remove the fuel filter housing.
Step 8

Unscrew the fuel filter cap fastener. Use a T30 Torx bit. Use a ratchet wrench.
Step 9

Remove the fastener.
Step 10

Remove the fuel filter cap.
Step 11

Remove the sealing ring.

Step 12

Remove the filter element from the fuel filter housing.
Step 13

Clean the fuel filter housing, cap, and cap fastener. Use an all-purpose cleaning spray.
Step 14

Install a new filter element into the fuel filter housing.
Step 15

Install a new sealing ring.
Step 16

Install the fuel filter cap.
Step 17

Install the fastener.
Step 18

Tighten the fuel filter cap fastener. Use a T30 Torx bit. Use a torque wrench. Tightening torque: 12 N·m.
Step 19

Install the fuel filter housing.
Step 20

Remove the plugs from the fuel lines and connect the lines to the fuel filter.
Step 21

Treat the electrical connector of the fuel filter. Use an electronic spray.
Step 22

Attach the electrical connector to the fuel filter.

Replacement: fuel filter – RENAULT MASTER II Platform/Chassis (ED/HD/UD). AUTODOC recommends:
After replacing the fuel filter, you may need to bleed the fuel system of air. Check your vehicle manufacturer's repair manual and follow the procedure listed there.
Step 23

Run the engine for a few minutes. This is necessary to ensure that the component works properly.

Step 24

Switch off the engine.

Caution!
Make sure there are no fuel leaks.
Step 25

Remove the fender cover.

Step 26

Close the bonnet.

Replacement: fuel filter – RENAULT MASTER II Platform/Chassis (ED/HD/UD). AUTODOC experts recommend:
To protect the environment from pollution, make sure to dispose of the used filters at designated collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Master II Platform/Chassis model

Renault Master 2 Platform tyre size

How to change engine oil and filter on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
2.25 MB
How to change air filter on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
942.08 KB
How to change rear brake pads on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
1.5 MB
How to change front brake pads on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
1.79 MB
How to change rear brake discs on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
2.24 MB
How to change front brake discs on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
2.57 MB

How to change fuel filter on Renault Master 2 van – replacement guide

Free download PDF
1.66 MB
How to change fuel filter on RENAULT Master II Minibus – replacement guide

Free download PDF
1.34 MB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Renault Megane Scenic – replacement guide

Free download PDF
1.66 MB
How to change fuel filter on Renault Clio 3 – replacement guide

Free download PDF
1.84 MB
How to change fuel filter on Renault Megane 2 – replacement guide

Free download PDF
942.08 KB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

5 tools that make car repair incredibly simple | AUTODOC tips

49K views

Published on: 25/01/2024
Top 5 reasons why your car squeals | AUTODOC Tips

10K views

Published on: 26/10/2023
Deep interior cleaning | Car transformation by detailing

7K views

Published on: 05/09/2024
#TPMS Explained: Why Your Light is On and How to Respond Safely

9K views

Published on: 28/09/2023