Recommended replacement interval for the part category Fuel filter : 4 year / 60000 km

Important!

This replacement procedure can be used for:
OPEL Astra G Coupe (T98) 1.6 16V (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 2.2 16V (F07), OPEL Astra G Coupe (T98) 1.8 16V (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 1.8 16V (F07), OPEL Astra G Coupe (T98) 1.6 16V (F07) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Astra G Coupe (T98) and other OPEL models

Fuel filter

        Fuel filter for Astra G Coupe (T98) Petrol (101 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (116 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (190 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (125 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (147 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (192 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (200 hp)
      
        Fuel filter for Astra G Coupe (T98) Petrol (103 hp)

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Tools you might need:

                        Torx bit T20
                      
                        Fuel line pliers
                      
                        Fluid container

Buy tools

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Tip from AUTODOC:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Take the following steps:

Step 1

Open the fuel door. Unscrew the fuel filler cap.

Step 2

Lift the car using a jack or place it over an inspection pit.

Step 3

Prepare a container for fluids.
Step 4

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use fuel line pliers.

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 5

Loosen the fuel filter mounting. Use Torx T20.
Step 6

Remove the fuel filter. Put the old filter cartridge in the container.
Step 7

Remove the retainers of the fasteners of the fuel filter tubes.
Step 8

Install the retainers of the fasteners of the fuel filter tubes.
Step 9

Install a new fuel filter.
Step 10

Tighten the fuel filter fasteners. Use Torx T20.

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Tip:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.

Step 12

Lower the car.

Step 13

Tighten the fuel filler cap. Close the fuel door.

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Professionals recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 14

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Replacement: fuel filter – OPEL ASTRA G Coupe (F07_). Tip from AUTODOC:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Astra G Coupe (T98) model.

Browse tyres

How to change air filter on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
1.8 MB
How to change engine oil and filter on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
1.59 MB
How to change pollen filter on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
2.19 MB
How to change front brake pads on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
1.75 MB
How to change rear brake pads on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
2.32 MB
How to change front brake discs on OPEL Astra G Coupe (T98) – replacement guide

Free download PDF
2.71 MB

How to change fuel filter on OPEL Astra H Hatchback (A04) – replacement guide

Free download PDF
1.57 MB
How to change fuel filter on OPEL Astra H GTC (A04) – replacement guide

Free download PDF
1.57 MB
How to change fuel filter on Opel Astra G F48 – replacement guide

Free download PDF
1.84 MB
How to change fuel filter on OPEL Astra H Saloon (A04) – replacement guide

Free download PDF
921.6 KB
How to change fuel filter on OPEL Astra H TwinTop (A04) – replacement guide

Free download PDF
921.6 KB
How to change fuel filter on OPEL Astra G Saloon (T98) – replacement guide

Free download PDF
1.58 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

DIY car soundproofing | AUTODOC tips

76K views

Published on: 15/04/2021
DIY alternator repair | AUTODOC tips

1M views

Published on: 30/11/2022
How to prevent car windows from fogging up | AUTODOC tips

12K views

Published on: 04/02/2021
TOP 5 mistakes when replacing shock absorbers | AUTODOC tips

8K views

Published on: 15/06/2023