Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
MINI Hatchback (R56) Cooper D, MINI Hatchback (R56) Cooper SD, MINI Hatchback (R56) Cooper D, MINI Hatchback (R56) One D … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Hatchback (R56) and other MINI models

Alternative products

Fuel filter

9F0011P RIDEX PLUS Fuel filter

9,91 GBP

Shop

SKFF-0870781 STARK Fuel filter

15,28 GBP

Shop

SKFF-0870010 STARK Fuel filter

15,42 GBP

Shop

9F0011 RIDEX Fuel filter

15,42 GBP

Shop

H337WK HENGST FILTER Fuel filter

21,58 GBP

Shop

F 026 402 085 BOSCH Fuel filter

22,30 GBP

Shop

KL 169/4D MAHLE ORIGINAL Fuel filter

22,50 GBP

Shop

KL 579D MAHLE ORIGINAL Fuel filter

22,70 GBP

Shop

H247WK01 HENGST FILTER Fuel filter

23,17 GBP

Shop

0 450 906 457 BOSCH Fuel filter

25,71 GBP

Shop

Replacement: fuel filter – MINI MINI (R56). Tools you need:

                      All-purpose cleaning spray
                    
                      Drive socket # 10 
                    
                      Torx bit T40
                    
                      Ratchet wrench
                    
                      Fluid container
                    
                      Flat Screwdriver

Buy tools

Replacement: fuel filter – MINI MINI (R56). Tip from AUTODOC experts:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Please note: all work on the car – MINI MINI (R56) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Lift the car using a jack or place it over an inspection pit.

Step 2

Prepare a container for fluids.
Step 3

Remove the snap ring of the fuel pressure regulator retainer clip. Use a flat screwdriver.
Step 4

Loosen the fastening clamp of the fuel filter pipe. Use a flat screwdriver.
Step 5

Loosen the fuel filter mounting. Use a drive socket #10. Use a ratchet wrench.
Step 6

Detach the tubes from the fuel filter.

Replacement: fuel filter – MINI MINI (R56). AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Remove the fuel filter. Put the old filter cartridge in the container.
Step 8

Unscrew the fuel filter bracket fixing bolts. Use Torx T40. Use a ratchet wrench.
Step 9

Remove the fuel filter fastening bracket.
Step 10

Install the fuel filter fastening bracket.
Step 11

Screw the fixing bolts of the fuel filter bracket. Use Torx T40. Use a ratchet wrench.
Step 12

Install a new fuel filter.

Replacement: fuel filter – MINI MINI (R56). Tip from AUTODOC:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.MINI MINI (R56) – It's important to only use high-quality filters.
Step 13

Attach the tubes to the fuel filter.
Step 14

Install the snap ring of the fuel pressure regulator's retainer clip.
Step 15

Screw in the fuel filter mounting bracket. Use a drive socket #10. Use a ratchet wrench.
Step 16

Tighten the fastening clamp of the fuel filter pipe. Use a flat screwdriver.
Step 17

Clean the fuel filter mounting bracket. Use all-purpose cleaning spray.
Step 18

Take the fluid container away from under the fuel filter.

Step 19

Lower the car.

Replacement: fuel filter – MINI MINI (R56). Tip from AUTODOC experts:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 20

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 21

Shut off the engine.

Replacement: fuel filter – MINI MINI (R56). Tip:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.