Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
AUDI A6 Saloon (4F2, C6) 2.0 TDI, AUDI A6 Saloon (4F2, C6) 2.0 TDI … View more

The steps may slightly vary depending on the car design.

How to change fuel filter AUDI A6 (C6) [TUTORIAL AUTODOC]

All the parts you need to replace – Fuel Filter for A6 Saloon (4F2, C6) and other AUDI models

Fuel filter

Seal, fuel filter

How to change Fuel filter on AUDI A6 Saloon (4F2, C6) 2.0 TDI – tips for proper car maintenance

Fuel filter for AUDI A6 Saloon (4F2, C6) 2.0 TDI Diesel (136 hp)

Simple DIY car repair steps – Replacing Fuel filter on AUDI A6 Saloon (4F2, C6) 2.0 TDI

Fuel filter for AUDI A6 Saloon (4F2, C6) 2.0 TDI Diesel (121 hp)

Replacement: fuel filter – Audi A6 4F2. Tools you might need:

                        All-purpose cleaning spray
                      
                        Torx bit T25
                      
                        Drive socket # 10 
                      
                        Flat Screwdriver
                      
                        Clic-R collar pliers
                      
                        Fender cover

Buy tools

Replacement: fuel filter – Audi A6 4F2. Tip from AUTODOC:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Audi A6 4F2. Take the following steps:

Step 1

Open the bonnet.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Remove the engine cover.

Replacement: fuel filter – Audi A6 4F2. Tip from AUTODOC:
Raise the engine cover, holding it on two sides simultaneously.
Step 4

Unscrew the fasteners of the coolant reservoir. Use Torx T25.
Step 5

Remove the coolant reservoir.
Step 6

Clean the fuel filter. Use all-purpose cleaning spray.
Step 7

Loosen the fastening clamp of the fuel filter pipe. Use clic-R collar pliers.

Step 8

Disconnect the pipe from the fuel filter.

Replacement: fuel filter – Audi A6 4F2. Tip from AUTODOC experts:
Be careful! Fuel may leak from the filter housing and hoses.
Step 9

Loosen the fuel filter mounting. Use a drive socket #10.
Step 10

Disconnect the pipe from the fuel filter.
Step 11

Remove the fuel filter. Put the old filter cartridge in the container.
Step 12

Remove the o-rings. Use a flat screwdriver.
Step 13

Install new o-rings. Use a flat screwdriver.
Step 14

Install a new fuel filter.

Replacement: fuel filter – Audi A6 4F2. Professionals recommend:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Audi A6 4F2 – It's important to only use high-quality car parts.
Step 15

Attach the pipe to the fuel filter.
Step 16

Attach the pipe to the fuel filter.
Step 17

Tighten the fuel filter fasteners. Use a drive socket #10.
Step 18

Tighten the fastening clamp of the fuel filter pipe. Use clic-R collar pliers.
Step 19

Install the coolant reservoir.
Step 20

Screw in the coolant reservoir fasteners. Use Torx T25.
Step 21

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.
Step 22

Shut off the engine.
Step 23

Install the engine cover and secure it.

Replacement: fuel filter – Audi A6 4F2. Tip from AUTODOC experts:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 24

Remove the fender protection cover.

Step 25

Close the hood.

Replacement: fuel filter – Audi A6 4F2. AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change pollen filter on Audi A6 4F2 – replacement guide

Free download PDF
1.29 MB
How to change air filter on Audi A6 4F2 – replacement guide

Free download PDF
983.04 KB
How to change engine oil and filter on AUDI A6 C6 Saloon (4F2) – replacement guide

Free download PDF
1.86 MB
How to change front brake pads on Audi A6 4F2 – replacement guide

Free download PDF
1.75 MB
How to change rear brake pads on Audi A6 4F2 – replacement guide

Free download PDF
1.53 MB
How to change rear brake discs on Audi A6 4F2 – replacement guide

Free download PDF
1.96 MB

How to change fuel filter on AUDI A6 Avant (4F5, C6) – replacement guide

Free download PDF
1.17 MB
How to change fuel filter on AUDI A6 C5 Saloon (4B2) – replacement guide

Free download PDF
2.13 MB
How to change fuel filter on Audi A6 C5 Avant – replacement guide

Free download PDF
1.42 MB
How to change fuel filter on AUDI A6 C6 Allroad (4FH) – replacement guide

Free download PDF
1.97 MB
How to change fuel filter on AUDI A6 Avant (4A5, C4) petrol – replacement guide

Free download PDF
901.12 KB
How to change fuel filter on AUDI A6 C4 Saloon (4A2) – replacement guide

Free download PDF
1.9 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

5 common car washing mistakes | AUTODOC tips

5K views

Published on: 23/09/2021
How to paint a car with a spray can | AUTODOC tips

5K views

Published on: 25/03/2021
DIY valve cover restoration | AUTODOC tips

6K views

Published on: 29/06/2023
Coolant comparison test | AUTODOC

4K views

Published on: 13/10/2022