Important!
This replacement procedure can be used for:
OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68), OPEL Astra F Classic CC (T92) 1.6 i (F08, M08, F68, M68), OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Wheel Bearing for Astra F Classic CC (T92) and other OPEL models
Tools
Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. List of the tools you'll need:
Wire brush
WD-40 spray
All-purpose cleaning spray
Brake cleaner
Ceramic grease
Copper grease
Torque wrench
Combination spanner #13
Combination spanner #18
Drive socket # 13
Drive socket # 17
Drive socket # 18
Drive socket # 30
HEX bit no.H5.
HEX bit no.H10.
Wheel impact socket #17
Ratchet wrench
Bush and bearing driver set
Bearing separator
Ball joint puller
Circlip pliers
Flat Screwdriver
Phillips Screwdriver
Tap wrench
Hammer
Rubber mallet
Crow bar
Wheel chock
AUTODOC recommends:
  • Do not re-use the bearing assembly of your OPEL ASTRA F CLASSIC Hatchback car.
  • The wheel hub bearing replacement procedure is identical for both wheels on the same axle.
  • Please note: all work on the car – OPEL ASTRA F CLASSIC Hatchback – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Secure the wheels with chocks.
    Step 2
    How to change Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 3
    Raise the car.
    Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. Professionals recommend:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 4
    How to replace OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 1999 Wheel Bearing - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. OPEL ASTRA F CLASSIC Hatchback
  3. Step 5
    OPEL ASTRA F CLASSIC Hatchback 1.6 i (F08, M08, F68, M68) 2000 Wheel Bearing replacement: free workshop manuals
    Remove the wheel.
  4. Step 6
    Changing Wheel Bearing on OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 2001 by yourself
    Remove the wheel hub nut cap. Use a crowbar. Use a hammer.
  5. Step 7
    How to remove OPEL ASTRA 1.6 i (F08, M08, F68, M68) 2002 Wheel Bearing - online easy-to-follow instructions
    Remove the cotter pin securing the hub nut. Use a crowbar. Use a flat screwdriver.
  6. Step 8
    How to replace Wheel Bearing on OPEL Astra F Classic CC (T92) 1998: download PDF manuals and video instructions
    Install the wheel.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. OPEL ASTRA F CLASSIC Hatchback
  7. Step 9
    How hard is it to do yourself: Wheel Bearing replacement on OPEL ASTRA F CLASSIC Hatchback 1.4 i (M08, M68, F08, F68) 1999 - download illustrated guide
    Screw in the wheel bolts. Use wheel impact socket #17.
  8. Step 10
    Need to know how to renew Wheel Bearing on OPEL ASTRA 2000? This free workshop manual will help you to do it yourself
    Lower the car.
  9. Step 11
    Changing of Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 2001 won't be an issue if you follow this illustrated step-by-step guide
    Loosen the fastener of the driveshaft. Use a drive socket #30. Use a tap wrench.
  10. Step 12
    OPEL ASTRA 1.6 i 16V (F08, M08, F68, M68) Wheel Bearing replacement: online guides and video tutorials
    Raise the car.
    AUTODOC recommends:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
  11. Step 13
    Replacing Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 1.4 i (M08, M68, F08, F68) by yourself
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. OPEL ASTRA F CLASSIC Hatchback
  12. Step 14
    Astra F Classic CC (T92) 1.6 i (F08, M08, F68, M68) 1999 Wheel Bearing DIY replacement workshop manual
    Remove the wheel.
  13. Step 15
    How to change Wheel Bearing on OPEL Astra F Classic CC (T92) 2000 - tips and tricks
    Unscrew the fastener connecting the drive shaft to the wheel hub. Use a drive socket #30. Use a ratchet wrench.
  14. Step 16
    Step-by-step recommendations for DIY replacement OPEL ASTRA F CLASSIC Hatchback 2001 1.6 i (F08, M08, F68, M68) Wheel Bearing
    Remove the wheel bearing washer. Use a crowbar.
  15. Step 17
    DIY replacement of Wheel Bearing on OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) 2002 is not an issue anymore with our step-by-step tutorial
    Spread the brake pads. Use a crowbar.
  16. Step 18
    How to change Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 - free PDF and video manuals
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  17. Step 19
    How to replace OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 1999 Wheel Bearing - step-by-step manuals and video guides
    Unscrew the caliper bracket fastening. Use HEX No.H10. Use a tap wrench. Use a ratchet wrench.
  18. Step 20
    OPEL ASTRA F CLASSIC Hatchback 1.6 i (F08, M08, F68, M68) 2000 Wheel Bearing replacement: free workshop manuals
    Remove the brake caliper together with its bracket.
    Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  19. Step 21
    Changing Wheel Bearing on OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 2001 by yourself
    Clean the brake disc fastener. Use a wire brush. Use all-purpose cleaning spray.
  20. Step 22
    How to remove OPEL ASTRA 1.6 i (F08, M08, F68, M68) 2002 Wheel Bearing - online easy-to-follow instructions
    Unscrew the brake disc fastening. Use a Phillips screwdriver.
  21. Step 23
    How to replace Wheel Bearing on OPEL Astra F Classic CC (T92) 1998: download PDF manuals and video instructions
    Remove the brake disc.
    Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. AUTODOC experts recommend:
    If necessary, use a rubber mallet.
  22. Step 24
    How hard is it to do yourself: Wheel Bearing replacement on OPEL ASTRA F CLASSIC Hatchback 1.4 i (M08, M68, F08, F68) 1999 - download illustrated guide
    Clean the fastener connecting the tie rod end to the steering knuckle. Use a wire brush. Use WD-40 spray.
  23. Step 25
    Need to know how to renew Wheel Bearing on OPEL ASTRA 2000? This free workshop manual will help you to do it yourself
    Unscrew the end fastening nut to the steering knuckle. Use a drive socket #17. Use a ratchet wrench.
  24. Step 26
    Changing of Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 2001 won't be an issue if you follow this illustrated step-by-step guide
    Disconnect the tie rod end from the steering knuckle. Use a ball joint puller.
  25. Step 27
    OPEL ASTRA 1.6 i 16V (F08, M08, F68, M68) Wheel Bearing replacement: online guides and video tutorials
    Clean the fastener connecting the ball joint to the steering knuckle. Use a wire brush. Use WD-40 spray.
  26. Step 28
    Replacing Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 1.4 i (M08, M68, F08, F68) by yourself
    Unscrew the ball joint fastening to the steering knuckle. Use a combination spanner #13. Use a drive socket #13. Use a ratchet wrench.
  27. Step 29
    Astra F Classic CC (T92) 1.6 i (F08, M08, F68, M68) 1999 Wheel Bearing DIY replacement workshop manual
    Remove the fastening bolt.
  28. Step 30
    Clean the lower fastener connecting the suspension strut to the steering knuckle. Use a wire brush. Use WD-40 spray.
    Step 31
    How to change Wheel Bearing on OPEL Astra F Classic CC (T92) 2000 - tips and tricks
    Unscrew the lower fastener connecting the shock strut to the steering knuckle. Use a combination spanner #18. Use a drive socket #18. Use a ratchet wrench.
  29. Step 32
    Step-by-step recommendations for DIY replacement OPEL ASTRA F CLASSIC Hatchback 2001 1.6 i (F08, M08, F68, M68) Wheel Bearing
    Clean the ABS sensor fastener. Use a wire brush. Use WD-40 spray.
  30. Step 33
    DIY replacement of Wheel Bearing on OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) 2002 is not an issue anymore with our step-by-step tutorial
    Unscrew the ABS sensor fastener. Use HEX No.H5. Use a ratchet wrench.
  31. Step 34
    How to change Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 - free PDF and video manuals
    Remove the fastening bolt.
  32. Step 35
    How to replace OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 1999 Wheel Bearing - step-by-step manuals and video guides
    Disconnect the ABS sensor.
  33. Step 36
    OPEL ASTRA F CLASSIC Hatchback 1.6 i (F08, M08, F68, M68) 2000 Wheel Bearing replacement: free workshop manuals
    Remove the fastening bolts.
  34. Step 37
    Changing Wheel Bearing on OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 2001 by yourself
    Disconnect the steering knuckle from the shock absorber strut.
  35. Step 38
    How to remove OPEL ASTRA 1.6 i (F08, M08, F68, M68) 2002 Wheel Bearing - online easy-to-follow instructions
    Detach the driveshaft from the steering knuckle.
    Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. AUTODOC recommends:
    Make sure that the drive shaft is not unloaded (when the car is jacked).
  36. Step 39
    How to replace Wheel Bearing on OPEL Astra F Classic CC (T92) 1998: download PDF manuals and video instructions
    Disconnect the ball joint from the steering knuckle.
  37. Step 40
    How hard is it to do yourself: Wheel Bearing replacement on OPEL ASTRA F CLASSIC Hatchback 1.4 i (M08, M68, F08, F68) 1999 - download illustrated guide
    Clean the wheel hub bearing retaining ring. Use a wire brush. Use WD-40 spray.
  38. Step 41
    Need to know how to renew Wheel Bearing on OPEL ASTRA 2000? This free workshop manual will help you to do it yourself
    Remove the wheel hub bearing retaining ring. Use circlip pliers.
  39. Step 42
    Changing of Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 2001 won't be an issue if you follow this illustrated step-by-step guide
    Remove the wheel hub from the steering knuckle. Use a bush and bearing driver set.
  40. Step 43
    OPEL ASTRA 1.6 i 16V (F08, M08, F68, M68) Wheel Bearing replacement: online guides and video tutorials
    Clean the wheel hub bearing retaining ring.
  41. Step 44
    Replacing Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 1.4 i (M08, M68, F08, F68) by yourself
    Clean the fasteners of the brake disc cover. Use a wire brush. Use WD-40 spray.
  42. Step 45
    Astra F Classic CC (T92) 1.6 i (F08, M08, F68, M68) 1999 Wheel Bearing DIY replacement workshop manual
    Unscrew the fasteners of the brake disc cover. Use a Phillips screwdriver.
  43. Step 46
    How to change Wheel Bearing on OPEL Astra F Classic CC (T92) 2000 - tips and tricks
    Remove the brake disc cover.
  44. Step 47
    Step-by-step recommendations for DIY replacement OPEL ASTRA F CLASSIC Hatchback 2001 1.6 i (F08, M08, F68, M68) Wheel Bearing
    Remove the wheel hub bearing retaining ring. Use circlip pliers.
  45. Step 48
    DIY replacement of Wheel Bearing on OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) 2002 is not an issue anymore with our step-by-step tutorial
    Press out the wheel hub bearing. Use a bush and bearing driver set.
  46. Step 49
    How to change Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 1998 - free PDF and video manuals
    Press out the inner bearing race that is remaining on the hub. Use a bearing separator.
  47. Step 50
    How to replace OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 1999 Wheel Bearing - step-by-step manuals and video guides
    Clean the hub bearing mounting seat. Use a wire brush. Use WD-40 spray. Use all-purpose cleaning spray.
  48. Step 51
    OPEL ASTRA F CLASSIC Hatchback 1.6 i (F08, M08, F68, M68) 2000 Wheel Bearing replacement: free workshop manuals
    Install the wheel hub bearing retaining ring. Use circlip pliers.
  49. Step 52
    Changing Wheel Bearing on OPEL Astra F Classic CC (T92) 1.4 i (M08, M68, F08, F68) 2001 by yourself
    Press-fit the new bearing into the steering knuckle. Use a bush and bearing driver set.
    Replacement: wheel bearing – OPEL ASTRA F CLASSIC Hatchback. Tip from AUTODOC experts:
    Check to make sure the wheel hub bearing is positioned correctly. Avoid its misalignment.
  50. Step 53
    How to remove OPEL ASTRA 1.6 i (F08, M08, F68, M68) 2002 Wheel Bearing - online easy-to-follow instructions
    Install the wheel hub bearing retaining ring. Use circlip pliers.
  51. Step 54
    How to replace Wheel Bearing on OPEL Astra F Classic CC (T92) 1998: download PDF manuals and video instructions
    Install the brake disc cover.
  52. Step 55
    How hard is it to do yourself: Wheel Bearing replacement on OPEL ASTRA F CLASSIC Hatchback 1.4 i (M08, M68, F08, F68) 1999 - download illustrated guide
    Tighten the fasteners of the brake disc back plate. Use a Phillips screwdriver. Use a torque wrench. Tighten it to 7 Nm torque.
  53. Step 56
    Need to know how to renew Wheel Bearing on OPEL ASTRA 2000? This free workshop manual will help you to do it yourself
    Clean the wheel hub mounting seat. Use all-purpose cleaning spray.
  54. Step 57
    Changing of Wheel Bearing on OPEL ASTRA F CLASSIC Hatchback 2001 won't be an issue if you follow this illustrated step-by-step guide
    Treat the wheel hub mounting seat. Use WD-40 spray.
  55. Step 58
    OPEL ASTRA 1.6 i 16V (F08, M08, F68, M68) Wheel Bearing replacement: online guides and video tutorials
    Press-fit a new bearing into the wheel hub. Use a bush and bearing driver set.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
OPEL Astra F Classic CC (T92) Wheel Bearing replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY OPEL Astra F Classic CC (T92) Wheel Bearing replacement - online guide
Tips & tricks for your OPEL Astra F Classic CC (T92)
View more
  • How to change Wheel bearings on OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) - replacement tricks
    What to do if the belt squeals | AUTODOC tips
  • Changing Hub bearing OPEL ASTRA F CLASSIC Hatchback 1.4 i (M08, M68, F08, F68) - Replacement Tips
    How to polish an old engine valve cover to a shiny finish | AUTODOC Tips
  • Maintenance Hacks - OPEL Astra F Classic CC (T92) 1.6 i (F08, M08, F68, M68) Wheel bearing kit replacement guide
    Top 5 reasons why the suspension knocks | AUTODOC tips
  • Replace Wheel hub bearing on OPEL ASTRA F CLASSIC Hatchback - free video tips
    How to find and change a fuse | AUTODOC

Professional manuals for the most common OPEL models