Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
OPEL Astra F Classic CC (T92) 1.6 i 16V (F08, M08, F68, M68) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Astra F Classic CC (T92) and other OPEL models

Alternative products

Brake pad set

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Torque wrench
                    
                      Combination spanner #13
                    
                      Combination spanner #17
                    
                      Drive socket # 13
                    
                      Wheel impact socket #17
                    
                      Brake caliper wind back tool
                    
                      Water pump pliers
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – OPEL ASTRA F CLASSIC Hatchback – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the rear of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. OPEL ASTRA F CLASSIC Hatchback
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Release the parking brake cable. Use water pump pliers. Use a crowbar.
Step 9

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #17.
Step 10

Spread the brake pads. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads. Use a crowbar.

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Tip from AUTODOC experts:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. After applying the spray, wait a few minutes.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Tip from AUTODOC:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Tip:
Make sure the pads are installed with linings facing the disc.
Step 16

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. After applying the spray, wait a few minutes.
Step 17

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 18

Install the brake caliper and fix it. Use a drive socket #13. Use a combination spanner #17. Use a torque wrench. Tighten it to 25 nm torque.
Step 19

Install the parking brake cable into the brake caliper bracket. Use water pump pliers. Use a crowbar.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – OPEL ASTRA F CLASSIC Hatchback. Professionals recommend:
After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. OPEL ASTRA F CLASSIC Hatchback
Step 23

Screw in the wheel bolts. Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 25

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap. Close the hood.

AUTODOC recommends:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Astra F Classic CC (T92) model

OPEL ASTRA F CLASSIC Hatchback tyre size

How to change wheel cylinder on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
2.07 MB
How to change rear brake shoes on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
1.57 MB
How to change front brake discs on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
1.92 MB
How to change front brake pads on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
1.46 MB
How to change rear wheel bearing on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
2.65 MB
How to change front wheel bearing on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
4.61 MB

How to change front brake pads on OPEL Astra H Hatchback (A04) – replacement guide

Free download PDF
1.45 MB
How to change rear brake pads on OPEL Astra H Hatchback (A04) – replacement guide

Free download PDF
2.32 MB
How to change rear brake pads on Opel Astra G F48 – replacement guide

Free download PDF
2.35 MB
How to change front brake pads on Opel Astra G F48 – replacement guide

Free download PDF
2.54 MB
How to change rear brake pads on OPEL Astra H GTC (A04) – replacement guide

Free download PDF
2.3 MB
How to change front brake pads on OPEL Astra H GTC (A04) – replacement guide

Free download PDF
1.45 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY alternator repair | AUTODOC tips

2M views

Published on: 30/11/2022
Revitalize Your Car Interior: DIY Steering Wheel Cover with AUTODOC Tips

6K views

Published on: 14/03/2024
#DIY Wheel Rim Restoration: Revive Scratches and Chips Easily!

7K views

Published on: 18/07/2024
What to do if your check engine light is on | AUTODOC tips

19K views

Published on: 19/08/2020