Important!

This replacement procedure can be used for:
HONDA ACCORD VIII Estate 2.0 i (CW1), HONDA ACCORD VIII Estate 2.4 i (CW2) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Springs for ACCORD VIII Estate and other HONDA models

Coil spring

Coil spring for Accord VIII Estate (CW) Petrol (156 hp)

Simple DIY car repair steps – Replacing Coil spring on Accord VIII Estate (CW)

Coil spring for Accord VIII Estate (CW) Petrol (201 hp)

Replacement: coil springs – HONDA ACCORD VIII Estate. List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Copper grease 
                      
                        Combination spanner #14
                      
                        Combination spanner #17
                      
                        Drive socket # 12 
                      
                        Drive socket # 14 
                      
                        Drive socket # 17 
                      
                        HEX bit No.H6
                      
                        Wheel impact socket #19
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Pin punch
                      
                        Tap wrench
                      
                        Hammer
                      
                        Flat chisel
                      
                        Rubber mallet
                      
                        Crow bar
                      
                        Hydraulic strut spring compressor
                      
                        Hydraulic transmission jack
                      
                        Fender cover
                      
                        Wheel chock

Buy tools

Replacement: coil springs – HONDA ACCORD VIII Estate. Tip from AUTODOC:

Both coil springs of the front suspension should be replaced simultaneously.
The replacement procedure is identical for the left and right coil springs of the front suspension.
Please note: all work on the car – HONDA ACCORD VIII Estate – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Clean the fasteners of the shock strut upper mount. Use WD-40 spray.
Step 4

Loosen the upper fastener of the shock strut mount. Use a drive socket #14. Use a ratchet wrench.
Step 5

Secure the wheels with chocks.
Step 6

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 7

Raise the front of the car and secure on supports.

Step 8

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. HONDA ACCORD VIII Estate
Step 9

Remove the wheel.
Step 10

Clean the shock strut fasteners. Use a wire brush. Use WD-40 spray.
Step 11

Unscrew the ABS cable holder. Use a drive socket #12. Use a ratchet wrench.
Step 12

Unscrew the fastening bolt that connects the shock strut with the shock absorber fork. Use a drive socket #14. Use a tap wrench.
Step 13

Undo the fastener that connects the shock strut with the shock absorber fork. Use a crowbar. Use a hammer.
Step 14

Pull aside the shock strut from its mounting seat.
Step 15

Clean the fastening bolt that connects the shock absorber fork with the lower control arm. Use a wire brush. Use WD-40 spray.
Step 16

Unscrew the fastening bolt that connects the shock absorber fork with the lower control arm. Use a combination spanner #17. Use a drive socket #17. Use a tap wrench.
Step 17

Remove the fastening bolt. Use a pin punch. Use a rubber mallet.
Step 18

Detach the shock absorber fork from the shock strut. Use a flat metal-working chisel. Use a hammer.
Step 19

Unscrew the top fastening of the shock strut mount. Use a drive socket #14. Use a ratchet wrench.

AUTODOC recommends:
HONDA ACCORD VIII Estate – To avoid injury, hold the suspension strut while unscrewing the fastening bolts.
Step 20

Support the arm. Use a hydraulic transmission jack.
Step 21

Disconnect the brake hose mounting bracket. Use a drive socket #12. Use a ratchet wrench.
Step 22

Remove the suspension strut.
Step 23

Set the shock absorber strut on the spring compressor tool.

Replacement: coil springs – HONDA ACCORD VIII Estate. Tip from AUTODOC:
Note that when using a spring compressor, spring coils need to be securely gripped, compressing the spring on the opposite sides.Ensure the correct position of the spring in the retainer.Make sure that the spring coils tightly entered the lock handles.
Step 24

Compress the spring.
Step 25

Remove the strut piston rod nut. Use a combination spanner #14. Use HEX No.H6. Use a ratchet wrench.
Step 26

Remove the top strut mount. Use a crowbar.
Step 27

Release the coil spring.
Step 28

Remove the spring.

AUTODOC recommends:
Replacement: coil springs – HONDA ACCORD VIII Estate. Carefully inspect the mount, the boot, and the bump stop of the shock absorber. Replace if necessary.
Step 29

Install the spring on the shock absorber.
Step 30

Compress the spring.
Step 31

Treat the fasteners of the shock strut mount. Use WD-40 spray.
Step 32

Install the upper strut mount and the strut mount bearing.
Step 33

Tighten the shock strut piston rod nut. Use a combination spanner #17. Use HEX No.H6. Use a torque wrench. Tighten it to 29 Nm torque.

AUTODOC recommends:
Check to make sure the spring is positioned correctly. Avoid its misalignment.
Step 34

Decompress the spring.
Step 35

Remove the assembled shock strut.
Step 36

Install the shock strut into the wheel arch.
Step 37

Screw the top fastening of the shock strut mount. Do not tighten it.

AUTODOC recommends:
HONDA ACCORD VIII Estate – To avoid injury, hold the suspension strut while screwing in the fastening bolts.
Step 38

Remove the support from under the arm.

AUTODOC recommends:
Replacement: coil springs – HONDA ACCORD VIII Estate. Lower the transmission jack smoothly, without jerks, to avoid damaging components and mechanisms.
Step 39

Clean the mounting seats of the shock absorber fork. Use a wire brush. Use WD-40 spray.
Step 40

Attach the shock absorber fork to the shock strut.
Step 41

Install the fastening bolt. Use a rubber mallet.
Step 42

Support the arm. Use a hydraulic transmission jack.
Step 43

Tighten the fastening bolt that connects the shock strut with the shock absorber fork. Use a drive socket #14. Use a torque wrench. Tighten it to 49 Nm torque.
Step 44

Tighten the fastening bolt that connects the shock absorber fork to the lower control arm. Use a combination spanner #17. Use a drive socket #17. Use a torque wrench. Tighten it to 64 Nm torque.
Step 45

Secure the brake hose fastening bracket. Use a drive socket #12. Use a ratchet wrench.
Step 46

Tighten the ABS cable holder. Use a drive socket #12. Use a ratchet wrench.
Step 47

Remove the support from under the arm.

AUTODOC recommends:
HONDA ACCORD VIII Estate – Do not lower the transmission jack sharply to avoid damaging components and mechanisms of the car.
Step 48

Treat the shock strut fasteners. Use copper grease.
Step 49

Clean the wheel rim mounting seat. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 50

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. HONDA ACCORD VIII Estate
Step 51

Screw in the wheel bolts. Use wheel impact socket #19.
Step 52

Tighten the upper fastener of the shock absorber strut mount. Use a drive socket #14. Use a torque wrench. Tighten it to 22 Nm torque.
Step 53

Treat the fasteners of the shock strut mount. Use copper grease.
Step 54

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 108 Nm torque.
Step 55

Remove the fender protection cover.

Step 56

Close the hood.

Step 57

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the HONDA Accord VIII Estate (CW) model.

Browse tyres

How to change front suspension strut on HONDA ACCORD VIII Estate – replacement guide

Free download PDF
3.16 MB
How to change front brake pads on HONDA ACCORD VIII Estate – replacement guide

Free download PDF
1.23 MB
How to change front brake discs on HONDA ACCORD VIII Estate – replacement guide

Free download PDF
1.78 MB
How to change engine oil and filter on HONDA Accord VIII Estate (CW) – replacement guide

Free download PDF
1.98 MB
How to change air filter on HONDA Accord VIII Estate (CW) – replacement guide

Free download PDF
1.61 MB
How to change pollen filter on HONDA ACCORD VIII Estate – replacement guide

Free download PDF
747.52 KB

How to change front coil springs on Honda Accord VIII CU – replacement guide

Free download PDF
4.51 MB
How to change coil springs on a car – replacement tutorial

Universal

Free download PDF
1.91 MB
How to change rear coil springs on Honda Jazz GD – replacement guide

Free download PDF
1.93 MB
How to change rear coil springs on Honda CR-V II – replacement guide

Free download PDF
2.55 MB
How to change front coil springs on Honda CR-V II – replacement guide

Free download PDF
3.17 MB
How to change front coil springs on VW Golf 6 – replacement guide

Free download PDF
4.16 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 4 car cleaning products | AUTODOC tips

2K views

Published on: 26/08/2021
The most common problems when buying a used car | AUTODOC

4K views

Published on: 10/11/2022
5 mistakes made when washing the engine | AUTODOC tips

29K views

Published on: 22/04/2021
How and why to check your oil | AUTODOC tips

5K views

Published on: 23/02/2023