Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VW CORRADO (53I) 2.8 VR6, VW CORRADO (53I) 1.8 16V, VW CORRADO (53I) 2.0 i, VW CORRADO (53I) 2.9 VR6, VW CORRADO (53I) 2.0 i 16V, VW CORRADO (53I) 1.8 G60 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for CORRADO (53I) and other VW models

Brake pad set

        Brake pad set for Corrado (53i) Petrol (160 hp)
      
        Brake pad set for Corrado (53i) Petrol (136 hp)
      
        Brake pad set for Corrado (53i) Petrol (190 hp)
      
        Brake pad set for Corrado (53i) Petrol (115 hp)
      
        Brake pad set for Corrado (53i) Petrol (136 hp)
      
        Brake pad set for Corrado (53i) Petrol (174 hp)

Replacement: brake pads – VW CORRADO (53I). List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Anti-squeal paste
                      
                        High-temperature ceramic grease
                      
                        Torque wrench
                      
                        Combination spanner #15
                      
                        Drive socket # 13 
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – VW CORRADO (53I). Tip from AUTODOC experts:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – VW CORRADO (53I). Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. VW CORRADO (53I)
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use a brake cleaner.

Step 8

Unscrew the brake caliper fastening. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper. Use a crowbar.

Replacement: brake pads – VW CORRADO (53I). AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.

Replacement: brake pads – VW CORRADO (53I). AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Treat the brake caliper piston. Use a brake cleaner.
Step 13

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VW CORRADO (53I). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 17.1

Install the brake caliper and fix it.

Step 17.2

Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use high-temperature ceramic grease.
Step 19

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VW CORRADO (53I). After applying the spray, wait a few minutes.
Step 20

Install the wheel.

Replacement: brake pads – VW CORRADO (53I). Tip from AUTODOC:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21

Screw in the wheel bolts. Use wheel impact socket #17.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 nm torque.
Step 23

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – VW CORRADO (53I). Check the brake fluid level in the reservoir and top up if necessary.
Step 24

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – VW CORRADO (53I). Professionals recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Corrado (53i) model.

Browse tyres

How to change rear brake pads on VW Corrado (53i) – replacement guide

Free download PDF
2.09 MB
How to change front wheel bearing on VW CORRADO (53I) – replacement guide

Free download PDF
4.06 MB
How to change rear wheel bearing on VW Corrado (53i) – replacement guide

Free download PDF
2.36 MB
How to change spark plugs on VW CORRADO (53I) – replacement guide

Free download PDF
1003.52 KB
How to change front windshield wipers on VW CORRADO (53I) – replacement guide

Free download PDF
737.28 KB
How to change engine oil and filter on VW Corrado (53i) – replacement guide

Free download PDF
1.63 MB

How to change rear brake pads on VW Corrado (53i) – replacement guide

Free download PDF
2.09 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on VW Polo 9N – replacement guide

Free download PDF
2.32 MB
How to change rear brake pads on VW Golf 6 – replacement guide

Free download PDF
2.2 MB
How to change rear brake pads on VW Golf 7 – replacement guide

Free download PDF
1.51 MB
How to change rear brake pads on VW Golf 5 – replacement guide

Free download PDF
2.38 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023
Causes of a worn car boot damper | AUTODOC

3K views

Published on: 04/07/2021
DIY brake caliper restoration | AUTODOC tips

557K views

Published on: 02/06/2022
What to check when buying a used car | AUTODOC tips

5K views

Published on: 24/10/2020