How to carry out replacement: Brake Pads E 220 CDi (210.606) MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210)
Disclaimer
Change MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) E 290 TD (210.617) Brake Pads yourself – manuals and video tutorials

How to change front brake pads on MERCEDES-BENZ E-Class Platform / Chassis (VF210) – replacement guide

downloads: 0
Views: 6
Download your free tutorial and fix MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 270 CDI (210.616) problems yourself Download for free 1.55 MB Brake Pads for MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your MERCEDES-BENZ E-CLASS
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 280 (210.663), MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 270 CDI (210.616) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for E-Class Platform / Chassis (VF210) and other MERCEDES-BENZ models
Alternative products
How to change Brake pad set on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) E 220 CDi (210.606) – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210). Tools you need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Ceramic grease
Torque wrench
Drive socket # 18
HEX bit No.H5
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Crow bar
Tap wrench
Brake caliper wind back tool
Long nose pliers
Wheel chock
Buy tools
AUTODOC recommends:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet.
    Step 2
    How to change Brake Pads on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) 1996 - free PDF and video manuals
    Unscrew the brake fluid reservoir cap.
  2. Step 3
    Secure the wheels with chocks.
    Step 4
    How to replace MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 220 CDi (210.606) 1997 Brake Pads - step-by-step manuals and video guides
    Loosen the wheel bolts. Use wheel impact socket #17. Use a tap wrench.
  3. Step 5
    Raise the car.
    Replacement: brake pads – MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210). Professionals recommend:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 6
    MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) E 250 d (210.610) 1998 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210)
  4. Step 7
    Changing Brake Pads on MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 290 TD (210.617) 1999 by yourself
    Remove the wheel.
  5. Step 8
    How to remove MERCEDES-BENZ E-CLASS E 280 (210.663) 2000 Brake Pads - online easy-to-follow instructions
    Detach the brake caliper retaining spring. Use a crowbar.
  6. Step 9
    How to replace Brake Pads on MERCEDES-BENZ E-Class Platform / Chassis (VF210) 2001: download PDF manuals and video instructions
    Disconnect the brake pad wear sensor. Use long nose pliers.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) E 250 d (210.610) 2002 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 11
    Need to know how to renew Brake Pads on MERCEDES-BENZ E-CLASS 2003? This free workshop manual will help you to do it yourself
    Remove the caps from the brake caliper guide pin boots. Use a crowbar.
  9. Step 12
    Changing of Brake Pads on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) 1996 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fasteners. Use HEX No.H7. Use a ratchet wrench.
  10. Step 13
    MERCEDES-BENZ E-CLASS E 290 TD (210.617) Brake Pads replacement: online guides and video tutorials
    Remove the brake caliper.
    AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  11. Step 14
    Replacing Brake Pads on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) 1998 E 220 CDi (210.606) by yourself
    Remove the brake pads.
    Replacement: brake pads – MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210). AUTODOC recommends:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  12. Step 15
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
    Step 16
    E-Class Platform / Chassis (VF210) E 280 (210.663) 1999 Brake Pads DIY replacement workshop manual
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
  13. Step 17
    How to change Brake Pads on MERCEDES-BENZ E-Class Platform / Chassis (VF210) 2000 - tips and tricks
    Press in the brake caliper piston. Use brake caliper wind back tool.
  14. Step 18
    Step-by-step recommendations for DIY replacement MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) 2001 E 280 (210.663) Brake Pads
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210). AUTODOC experts recommend:
    Make sure the disc surface is clean before installing the pads.
  15. Step 19
    DIY replacement of Brake Pads on MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 270 CDI (210.616) 2002 is not an issue anymore with our step-by-step tutorial
    Install new brake pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the MERCEDES-BENZ E-Class Platform / Chassis (VF210) model

MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) tyre size

Popular maintenance tutorials for MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210)

More manuals for MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210)

Complete guides for changing the Brake pad set on different MERCEDES-BENZ E-CLASS models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY MERCEDES-BENZ E-Class Platform / Chassis (VF210) Brake Pads replacement - online guide
Tips & tricks for your MERCEDES-BENZ E-Class Platform / Chassis (VF210)
View more
  • How to change Brake pad set on MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 270 CDI (210.616) - replacement tricks
    Kolbenschmidt plastic gauge overview
    2K views
    Published on: 23/04/2025
  • Changing Disc pads MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) E 220 CDi (210.606) - Replacement Tips
    BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project
    2K views
    Published on: 04/03/2021
  • Maintenance Hacks - MERCEDES-BENZ E-Class Platform / Chassis (VF210) E 250 d (210.610) Brake pad kit replacement guide
    Which Coolant is Best? Comparison Test | AUTODOC
    7K views
    Published on: 13/10/2022
  • Replace Disc brake pads on MERCEDES-BENZ E-Klasse Pritsche / Fahrgestell (VF210) - free video tips
    How to replace a timing chain yourself
    19K views
    Published on: 12/12/2024

Most commonly replaced car parts on MERCEDES-BENZ E-CLASS

Professional manuals for the most common MERCEDES-BENZ models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
MERCEDES-BENZ E-Class Platform / Chassis (VF210) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME