How to carry out replacement: Brake Pads 2.6 Audi A6 C4
Disclaimer
Change Audi A6 C4 2.0 Brake Pads yourself – manuals and video tutorials

How to change front brake pads on AUDI A6 Saloon (4A2, C4) – replacement guide

downloads: 2
Views: 31
Download your free tutorial and fix AUDI A6 Saloon (4A2, C4) 1.9 TDI problems yourself Download for free 1.59 MB Brake Pads for Audi A6 C4 Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your AUDI A6
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
AUDI A6 Saloon (4A2, C4) 2.6, AUDI A6 Saloon (4A2, C4) 2.6 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for A6 Saloon (4A2, C4) and other AUDI models
Alternative products
How to change Brake pad set on Audi A6 C4 2.6 – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – AUDI A6 (4A, C4). Tools you need:
Wire brush
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit no.H7.
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – AUDI A6 (4A, C4). AUTODOC recommends:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake pads – AUDI A6 (4A, C4). Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Pads on Audi A6 C4 1994 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace AUDI A6 Saloon (4A2, C4) 2.6 1995 Brake Pads - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    Audi A6 C4 2.5 TDI 1996 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake pads – AUDI A6 (4A, C4). Tip:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Pads on AUDI A6 Saloon (4A2, C4) S6 2.2 Turbo quattro 1997 by yourself
    Remove the wheel.
  5. Step 7
    How to remove AUDI A6 2.6 quattro 1994 Brake Pads - online easy-to-follow instructions
    Disconnect the brake pads wear sensor. Use a crowbar.
    Please note!
    Some cars are not equipped with the brake pad wear sensor.
  6. Step 8
    How to replace Brake Pads on AUDI A6 Saloon (4A2, C4) 1995: download PDF manuals and video instructions
    Spread the brake pads. Use a crowbar.
  7. Step 9
    How hard is it to do yourself: Brake Pads replacement on Audi A6 C4 1.8 1996 - download illustrated guide
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  8. Step 10
    Need to know how to renew Brake Pads on AUDI A6 1997? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  9. Step 11
    Changing of Brake Pads on Audi A6 C4 1994 won't be an issue if you follow this illustrated step-by-step guide
    Detach the brake caliper retaining spring. Use a crowbar.
  10. Step 12
    AUDI A6 2.0 Brake Pads replacement: online guides and video tutorials
    Remove the brake caliper.
    Replacement: brake pads – AUDI A6 (4A, C4). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 13
    Replacing Brake Pads on Audi A6 C4 1996 2.6 by yourself
    Remove the brake pads.
    Replacement: brake pads – AUDI A6 (4A, C4). Tip from AUTODOC:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  12. Step 14
    A6 Saloon (4A2, C4) 2.6 quattro 1997 Brake Pads DIY replacement workshop manual
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    Replacement: brake pads – AUDI A6 (4A, C4). Professionals recommend:
    After applying the spray, wait a few minutes.
  13. Step 15
    How to change Brake Pads on AUDI A6 Saloon (4A2, C4) 1994 - tips and tricks
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – AUDI A6 (4A, C4). After applying the spray, wait a few minutes.
  14. Step 16
    Step-by-step recommendations for DIY replacement Audi A6 C4 1995 2.6 quattro Brake Pads
    Press in the brake caliper piston. Use brake caliper wind back tool.
  15. Step 17
    DIY replacement of Brake Pads on AUDI A6 Saloon (4A2, C4) 2.5 TDI quattro 1996 is not an issue anymore with our step-by-step tutorial
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    AUTODOC recommends:
    Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A6 C4 Saloon (4A2) model

Audi A6 C4 tyre size

Popular maintenance tutorials for Audi A6 C4

More manuals for Audi A6 C4

Complete guides for changing the Brake pad set on different AUDI A6 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI A6 Saloon (4A2, C4) Brake Pads replacement - online guide
Tips & tricks for your AUDI A6 Saloon (4A2, C4)
View more
  • How to change Brake pad set on AUDI A6 Saloon (4A2, C4) 2.5 TDI quattro - replacement tricks
    How to Fix P0401 ✅ error code Insufficient EGR flow
    4K views
    Published on: 08/05/2025
  • Changing Disc pads Audi A6 C4 2.6 - Replacement Tips
    Understanding Airbag Light Warnings | Essential Tips for Car Safety
    6K views
    Published on: 10/04/2023
  • Maintenance Hacks - AUDI A6 Saloon (4A2, C4) 2.5 TDI Brake pad kit replacement guide
    Extend your engine's life: Avoid these 3 damaging factors | AUTODOC tips
    9K views
    Published on: 07/10/2021
  • Replace Disc brake pads on Audi A6 C4 - free video tips
    5 Essential Tips for beginner drivers: Avoid Common Mistakes
    4K views
    Published on: 31/01/2023

Most commonly replaced car parts on AUDI A6

Professional manuals for the most common AUDI models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI A6 Saloon (4A2, C4) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME