Recommended replacement interval for the part category Brake Pad Set, disc brake : 30000 km

Important!

This replacement procedure can be used for:
AUDI A6 Avant (4F5, C6) S6 quattro, AUDI A6 Avant (4F5, C6) 4.2 FSI quattro, AUDI A6 Avant (4F5, C6) 3.0 TDI quattro, AUDI A6 Avant (4F5, C6) 3.0, AUDI A6 Avant (4F5, C6) 2.0 TDI, AUDI A6 Avant (4F5, C6) 2.0 TDI, AUDI A6 Avant (4F5, C6) 2.7 TDI quattro, AUDI A6 Avant (4F5, C6) 3.0 quattro, AUDI A6 Avant (4F5, C6) 2.8 FSI, AUDI A6 Avant (4F5, C6) 2.8 FSI quattro, AUDI A6 Avant (4F5, C6) 2.0 TDI, AUDI A6 Avant (4F5, C6) 2.7 TDI, AUDI A6 Avant (4F5, C6) 2.7 TDI quattro, AUDI A6 Avant (4F5, C6) 2.8 FSI, AUDI A6 Avant (4F5, C6) 2.8 FSI, AUDI A6 Avant (4F5, C6) 2.8 FSI quattro, AUDI A6 Avant (4F5, C6) 2.8 FSI quattro, AUDI A6 Avant (4F5, C6) 3.0 TDI quattro, AUDI A6 Avant (4F5, C6) 3.0 TFSI quattro, AUDI A6 Avant (4F5, C6) 2.0 TDI, AUDI A6 Avant (4F5, C6) 3.0 TFSI quattro, AUDI A6 Avant (4F5, C6) 2.0 TDI, AUDI A6 Avant (4F5, C6) 2.7 TDI, AUDI A6 Avant (4F5, C6) 2.7 TDI, AUDI A6 Avant (4F5, C6) 3.0 TDI quattro, AUDI A6 Avant (4F5, C6) 2.7 TDI quattro, AUDI A6 Avant (4F5, C6) 3.2 FSI, AUDI A6 Avant (4F5, C6) 3.2 FSI quattro, AUDI A6 Avant (4F5, C6) 4.2 quattro, AUDI A6 Avant (4F5, C6) 2.4, AUDI A6 Avant (4F5, C6) 2.4 quattro, AUDI A6 Avant (4F5, C6) 3.0 TDI quattro, AUDI A6 Avant (4F5, C6) 2.0 TFSI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for A6 Avant (4F5, C6) and other AUDI models

Brake Pad Set, disc brake

        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 3.0 Petrol (218 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 2.7 TDI Diesel (180 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 3.2 FSI quattro Petrol (255 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 2.8 FSI Petrol (220 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 3.0 TFSI quattro Petrol (299 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 2.0 TDI Diesel (121 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 4.2 FSI quattro Petrol (350 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 2.7 TDI quattro Diesel (180 hp)
      
        Brake Pad Set, disc brake for AUDI A6 Avant (4F5, C6) 2.0 TDI Diesel (163 hp)

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Tools you need:

                        Wire brush
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        HEX bit no.H7.
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – AUDI A6 Avant (4F5, C6). AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Use the following procedure:

Step 1

Open the bonnet.Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts.Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Tip:

To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Disconnect the brake pads wear sensor. Use a crowbar.

Please note!

Some cars are not equipped with the brake pad wear sensor.
Step 8

Spread the brake pads.Use a crowbar.
Step 9

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 10

Unscrew the brake caliper fastening.Use HEX No.H7.Use a ratchet wrench.
Step 11

Detach the brake caliper retaining spring.Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). AUTODOC experts recommend:

Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Tip from AUTODOC:

Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust.Use a wire brush.Use a brake cleaner.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Professionals recommend:

After applying the spray, wait a few minutes.
Step 15

Treat the brake caliper piston.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake pads – AUDI A6 Avant (4F5, C6). After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston.Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:

Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Tip from AUTODOC:

Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it.Use HEX No.H7.Use a torque wrench.Tighten it to 30 Nm torque.
Step 20

Install the dust boot caps of the brake caliper guide pins.
Step 21

Connect the brake pads wear sensor.
Step 22

Install the brake caliper retaining spring. Use a crowbar.
Step 23

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 24

Clean the brake disk surface.Use a brake cleaner.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Tip from AUTODOC experts:

After applying the spray, wait a few minutes.
Step 25

Install the wheel.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). AUTODOC recommends:

To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 26

Screw in the wheel bolts.Use wheel impact socket #17.
Step 27

Lower the car and working in a cross order, tighten the wheel bolts.Use a torque wrench.Tighten it to 120 Nm torque.
Step 28

Remove the jacks and chocks.

AUTODOC recommends:

Important! Replacement: brake pads – AUDI A6 Avant (4F5, C6). Check the brake fluid level in the reservoir and top up if necessary.

Step 29

Tighten the brake fluid reservoir cap.

AUTODOC recommends:

AUDI A6 Avant (4F5, C6) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.

Step 30

Close the hood.

Replacement: brake pads – AUDI A6 Avant (4F5, C6). Professionals recommend:

Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change rear brake discs on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

1.9 MB
How to change front brake discs on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

2.02 MB
How to change rear brake pads on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

1.49 MB
How to change front wheel bearing on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

3.59 MB
How to change rear wheel bearing on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

2.52 MB
How to change serpentine belt on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

1.5 MB

How to change front brake pads on Audi A6 4F2 – replacement guide

Free download PDF

1.75 MB
How to change rear brake pads on Audi A6 4F2 – replacement guide

Free download PDF

1.53 MB
How to change rear brake pads on AUDI A6 C6 Avant (4F5) – replacement guide

Free download PDF

1.49 MB
How to change front brake pads on Audi A6 C5 Avant – replacement guide

Free download PDF

6.9 MB
How to change rear brake pads on Audi A6 C5 Avant – replacement guide

Free download PDF

5.65 MB
How to change rear brake pads on AUDI A6 C5 Saloon (4B2) – replacement guide

Free download PDF

2.47 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your AUDI A6 Avant (4F5, C6)

How to start a car after a long idle period | AUTODOC tips

5K views

Published on: 20/05/2021
How to clean an EGR valve | AUTODOC tips

86K views

Published on: 22/07/2020
How to prevent car windows from fogging up | AUTODOC tips

7K views

Published on: 04/02/2021
DIY car soundproofing | AUTODOC tips

44K views

Published on: 15/04/2021