How to carry out replacement: Brake Discs 2.0 TDI VW CADDY IV Box (SAA, SAH)
Disclaimer
Change VW CADDY IV Box (SAA, SAH) 1.6 TDI Brake Discs yourself – manuals and video tutorials

How to change front brake discs on VW CADDY IV Box (SAA, SAH) – replacement guide

downloads: 2
Views: 14
Download your free tutorial and fix VW CADDY IV Box (SAA, SAH) 1.4 TGI CNG problems yourself Download for free 2.26 MB Brake Discs for VW CADDY IV Box (SAA, SAH) Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your VW CADDY
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW CADDY IV Box (SAA, SAH) 1.2 TSI, VW CADDY IV Box (SAA, SAH) 1.4 TGI CNG, VW CADDY IV Box (SAA, SAH) 1.6 TDI, VW CADDY IV Box (SAA, SAH) 1.6 TDI, VW CADDY IV Box (SAA, SAH) 2.0 TDI, VW CADDY IV Box (SAA, SAH) 2.0 TDI, VW CADDY IV Box (SAA, SAH) 2.0 TDI 4motion, VW CADDY IV Box (SAA, SAH) 2.0 TDI 4motion, VW CADDY IV Box (SAA, SAH) 1.0 TSI, VW CADDY IV Box (SAA, SAH) 2.0 TDI, VW CADDY IV Box (SAA, SAH) 1.6, VW CADDY IV Box (SAA, SAH) ABT e-Caddy … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for CADDY IV Box (SAA, SAH) and other VW models
Alternative products
How to change Brake disc on VW CADDY IV Box (SAA, SAH) 2.0 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – VW CADDY IV Box (SAA, SAH). Tools you might need:
Wire brush
Nylon cleaning brush
WD-40 spray
All-purpose cleaning spray
Brake cleaner
Anti-squeal paste
Ceramic grease
Torque wrench
Combination spanner #17
Drive socket # 13
Drive socket # 19
Drive socket # 21
Torx bit T30
Wheel impact socket #17
Ratchet wrench
Rubber mallet
Impact screwdriver
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
AUTODOC recommends:
  • Replace the brake disks on the car VW CADDY IV Box (SAA, SAH) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – VW CADDY IV Box (SAA, SAH) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Brake Discs on VW CADDY IV Box (SAA, SAH) 2015 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    Secure the wheels with chocks.
    Step 3
    How to replace VW CADDY IV Box (SAA, SAH) 2.0 TDI 2016 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the car.
    Replacement: brake discs – VW CADDY IV Box (SAA, SAH). Professionals recommend:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 5
    VW CADDY IV Box (SAA, SAH) 1.4 TGI CNG 2017 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW CADDY IV Box (SAA, SAH)
  4. Step 6
    Changing Brake Discs on VW CADDY IV Box (SAA, SAH) 2.0 TDI 4motion 2018 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VW CADDY 1.2 TSI 2019 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VW CADDY IV Box (SAA, SAH). After applying the spray, wait a few minutes.
  6. Step 8
    How to replace Brake Discs on VW CADDY IV Box (SAA, SAH) 2020: download PDF manuals and video instructions
    Unscrew the brake caliper fasteners. Use a combination spanner #17. Use a drive socket #13. Use a ratchet wrench.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on VW CADDY IV Box (SAA, SAH) 2.0 TDI 2021 - download illustrated guide
    Remove the fastening bolts.
  8. Step 10
    Need to know how to renew Brake Discs on VW CADDY 2022? This free workshop manual will help you to do it yourself
    Spread the brake pads. Use a crowbar.
  9. Step 11
    Changing of Brake Discs on VW CADDY IV Box (SAA, SAH) 2023 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – VW CADDY IV Box (SAA, SAH). AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  10. Step 12
    VW CADDY 1.6 TDI Brake Discs replacement: online guides and video tutorials
    Remove the brake pads. Use a crowbar.
  11. Step 13
    Replacing Brake Discs on VW CADDY IV Box (SAA, SAH) 2025 2.0 TDI by yourself
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 14
    CADDY IV Box (SAA, SAH) 1.2 TSI 2015 Brake Discs DIY replacement workshop manual
    Unscrew the brake caliper bracket fasteners. Use a drive socket #21. Use a ratchet wrench.
  13. Step 15
    How to change Brake Discs on VW CADDY IV Box (SAA, SAH) 2016 - tips and tricks
    Remove the fastening bolts.
  14. Step 16
    Step-by-step recommendations for DIY replacement VW CADDY IV Box (SAA, SAH) 2017 1.2 TSI Brake Discs
    Remove the caliper bracket.
  15. Step 17
    DIY replacement of Brake Discs on VW CADDY IV Box (SAA, SAH) 1.6 TDI 2018 is not an issue anymore with our step-by-step tutorial
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  16. Step 18
    How to change Brake Discs on VW CADDY IV Box (SAA, SAH) 2015 - free PDF and video manuals
    Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
  17. Step 19
    How to replace VW CADDY IV Box (SAA, SAH) 2.0 TDI 2016 Brake Discs - step-by-step manuals and video guides
    Remove the fastening bolt.
  18. Step 20
    VW CADDY IV Box (SAA, SAH) 1.4 TGI CNG 2017 Brake Discs replacement: free workshop manuals
    Remove the brake disc. Use a rubber mallet.
  19. Step 21
    Changing Brake Discs on VW CADDY IV Box (SAA, SAH) 2.0 TDI 4motion 2018 by yourself
    Clean the hub. Use a wire brush. Use all-purpose cleaning spray.
  20. Step 22
    How to remove VW CADDY 1.2 TSI 2019 Brake Discs - online easy-to-follow instructions
    Treat the contacting surface. Use ceramic grease.
  21. Step 23
    How to replace Brake Discs on VW CADDY IV Box (SAA, SAH) 2020: download PDF manuals and video instructions
    Install the brake disc.
  22. Step 24
    How hard is it to do yourself: Brake Discs replacement on VW CADDY IV Box (SAA, SAH) 2.0 TDI 2021 - download illustrated guide
    Install the fastening bolt.
  23. Step 25
    Need to know how to renew Brake Discs on VW CADDY 2022? This free workshop manual will help you to do it yourself
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 8 Nm torque.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Caddy IV Van (SAA, SAH) model

VW CADDY IV Box (SAA, SAH) tyre size

Popular maintenance tutorials for VW CADDY IV Box (SAA, SAH)

More manuals for VW CADDY IV Box (SAA, SAH)

Complete guides for changing the Brake rotors on different VW CADDY models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VW CADDY IV Box (SAA, SAH) Brake Discs replacement - online guide
Tips & tricks for your VW CADDY IV Box (SAA, SAH)
View more
  • How to change Brake rotors on VW CADDY IV Box (SAA, SAH) 1.6 TDI - replacement tricks
    TOP 8 mistakes car owners make | AUTODOC tips
    14K views
    Published on: 09/12/2021
  • Changing Brake disc VW CADDY IV Box (SAA, SAH) 2.0 TDI - Replacement Tips
    #DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit
    8K views
    Published on: 14/12/2023
  • Maintenance Hacks - VW CADDY IV Box (SAA, SAH) 1.4 TGI CNG Rotors replacement guide
    Understanding Car Tools: The Key Differences You Need to Know | AUTODOC tips
    8K views
    Published on: 16/12/2021
  • Replace Disc brakes on VW CADDY IV Box (SAA, SAH) - free video tips
    How to fix your car with AUTODOC CLUB
    17K views
    Published on: 30/11/2021

Most commonly replaced car parts on VW CADDY

Professional manuals for the most common VW models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VW CADDY IV Box (SAA, SAH) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME