Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
RENAULT LOGAN I Estate (KS_) 1.4, RENAULT LOGAN I Estate (KS_) 1.6 (KS0L, KS0M, KS0P, KS1S), RENAULT LOGAN I Estate (KS_) 1.6, RENAULT LOGAN I Estate (KS_) 1.5 dCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for LOGAN I Estate (KS_) and other RENAULT models

Alternative products

Brake disc

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). List of the tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Combination spanner #13
                    
                      Combination spanner #17
                    
                      Drive socket # 18 
                    
                      Torx bit T40
                    
                      Wheel impact socket #19
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Tap wrench
                    
                      Impact screwdriver
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). Tip:

Replace the brake disks on the car RENAULT LOGAN I Estate (KS_) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Please note: all work on the car – RENAULT LOGAN I Estate (KS_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #17.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.
Step 12

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 13

Unscrew the caliper bracket fastening. Use a drive socket #18. Use a ratchet wrench. Use a tap wrench.
Step 14

Remove the caliper bracket.
Step 15

Clean the brake disk surface. Use a wire brush. Use WD-40 spray.
Step 16

Unscrew the brake disc fastening. Use Torx T40. Use an impact screwdriver.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). Tip from AUTODOC:
If necessary, use a rubber mallet.
Step 17

Remove the brake disc.
Step 18

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 19

Install the brake disc.
Step 20

Tighten the brake disc fastening. Use Torx T40. Use a torque wrench. Tighten it to 15 Nm torque.
Step 21

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). Professionals recommend:
After applying the spray, wait a few minutes.
Step 22

Install the brake caliper bracket.
Step 23

Tighten the brake caliper bracket. Use a drive socket #18. Use a torque wrench. Tighten it to 100 Nm torque.
Step 24

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – RENAULT LOGAN I Estate (KS_). After applying the spray, wait a few minutes.
Step 25

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 26

Install the brake pads.
Step 27

Install the brake caliper and fix it. Use a combination spanner #13. Use a combination spanner #17. Use a torque wrench. Tighten it to 35 Nm torque.
Step 28

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 29

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 30

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. RENAULT LOGAN I Estate (KS_)
Step 31

Screw in the wheel bolts. Use wheel impact socket #19.
Step 32

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 90 Nm torque.
Step 33

Remove the jacks and chocks.

Replacement: brake discs – RENAULT LOGAN I Estate (KS_). Tip:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 34

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
RENAULT LOGAN I Estate (KS_) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.
Step 35

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Logan I Estate (KS) model

Renault Logan Estate tyre size

How to change rear wheel bearing on RENAULT LOGAN I Estate (KS_) – replacement guide

Free download PDF
1.24 MB
How to change front wheel bearing on RENAULT Logan I Estate (KS) – replacement guide

Free download PDF
4.31 MB
How to change serpentine belt on RENAULT Logan I Estate (KS) – replacement guide

Free download PDF
1.95 MB
How to change spark plugs on RENAULT LOGAN I Estate (KS_) – replacement guide

Free download PDF
880.64 KB
How to change engine oil and filter on RENAULT Logan I Estate (KS) – replacement guide

Free download PDF
1.99 MB
How to change air filter on RENAULT Logan I Estate (KS) – replacement guide

Free download PDF
2.02 MB

How to change front brake discs on RENAULT Logan I Saloon – replacement guide

Free download PDF
1.92 MB
How to change front brake discs on RENAULT Logan / Stepway II Saloon (L8_) – replacement guide

Free download PDF
1.95 MB
How to change front brake discs on RENAULT Logan Express (US_) – replacement guide

Free download PDF
2.01 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change front brake discs on Renault Clio 2 – replacement guide

Free download PDF
1.99 MB
How to change front brake discs on Renault Megane Scenic – replacement guide

Free download PDF
2.61 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 7 Manual Transmission Mistakes to Avoid | AUTODOC Tips

6K views

Published on: 20/10/2020
Top 5 reasons why your car squeals | AUTODOC Tips

9K views

Published on: 26/10/2023
BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project

2K views

Published on: 04/03/2021
How to prevent car windows from fogging up | AUTODOC tips

13K views

Published on: 04/02/2021