
Disclaimer
How to change front brake discs on Peugeot 307 SW – replacement guide
downloads:
5
Views:
190

Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
PEUGEOT 307 SW (3H) 1.6 16V, PEUGEOT 307 SW (3H) 2.0 16V, PEUGEOT 307 SW (3H) 2.0 HDI, PEUGEOT 307 SW (3H) 2.0 HDI, PEUGEOT 307 SW (3H) 1.4 16V, PEUGEOT 307 SW (3H) 1.6 HDI, PEUGEOT 307 SW (3H) 2.0 16V, PEUGEOT 307 SW (3H) 1.6 HDI, PEUGEOT 307 SW (3H) 1.6 BioFlex … View more
The steps may slightly vary depending on the car design.
PEUGEOT 307 SW (3H) 1.6 16V, PEUGEOT 307 SW (3H) 2.0 16V, PEUGEOT 307 SW (3H) 2.0 HDI, PEUGEOT 307 SW (3H) 2.0 HDI, PEUGEOT 307 SW (3H) 1.4 16V, PEUGEOT 307 SW (3H) 1.6 HDI, PEUGEOT 307 SW (3H) 2.0 16V, PEUGEOT 307 SW (3H) 1.6 HDI, PEUGEOT 307 SW (3H) 1.6 BioFlex … View more
The steps may slightly vary depending on the car design.
How to change front brake discs / brake rotors on PEUGEOT 307 SW [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Discs for 307 SW (3H) and other PEUGEOT models
Brake disc
Alternative products

Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
HEX bit No.H7.
Torx bit T30
Torx bit T50
Wheel impact socket #17
Ratchet wrench
Tap wrench
Brake caliper wind back tool
Impact screwdriver
Crow bar
Fender cover
Wheel chock
Replacement: brake discs – Peugeot 307 SW. Tip from AUTODOC:
- Replace the brake disks on the car Peugeot 307 SW in complete set for each axis. Regardless of the state of components. This will ensure even braking.
- The replacement procedure is identical for both brake disks on the same axle.
- When changing the brake discs, always replace the brake pads.
- Warning! Shut down the engine before starting any work – Peugeot 307 SW
Carry out replacement in the following order:
- Step 1Open the bonnet.
- Step 2Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.Step 3Unscrew the brake fluid reservoir cap.
- Step 4Secure the wheels with chocks.
- Step 5Loosen the wheel mounting bolts. Use wheel impact socket #17.
- Step 6Raise the front of the car and secure on supports.
- Step 7Unscrew the wheel bolts.AUTODOC recommends:Important! Hold the wheel while unscrewing the fastening bolts. Peugeot 307 SW
- Step 8Remove the wheel.
- Step 9Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
- Step 10Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
- Step 11Spread the brake pads. Use a crowbar.
- Step 12Detach the brake caliper retaining spring. Use a crowbar.
- Step 13Remove the brake caliper.Replacement: brake discs – Peugeot 307 SW. Professionals recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
- Step 14Remove the brake pads.
- Step 15Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
- Step 16Unscrew the caliper bracket fastening. Use Torx T50. Use a tap wrench.
- Step 17Remove the caliper bracket.
- Step 18Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.Step 19Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
- Step 20Remove the brake disc.
- Step 21Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
- Step 22Install the brake disc.
- Step 23Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 9 Nm torque.
- Step 24Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake discs – Peugeot 307 SW. After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?
Find out which tyre and wheel sizes are compatible with the PEUGEOT 307 SW (3H) model
Popular maintenance tutorials for Peugeot 307 SW
Complete guides for changing the Brake rotors on different PEUGEOT 307 models
Unlock your car maintenance assistant!
Track expenses, manage logs, schedule replacements, and more.
Tips & tricks for your PEUGEOT 307 SW (3H)
View more
- Save Money on Fuel with These Easy Tips | AUTODOC
- How to Get the Best Deals on Car Parts | Save Money with AUTODOC
- Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC
- Coolant comparison test | AUTODOC
Most commonly replaced car parts on PEUGEOT 307
Time to replace parts? Get even better deals in our Shop app.

SCAN ME