How to carry out replacement: Brake Discs 2.0 TDI Audi A4 B7 Avant
Disclaimer
Change Audi A4 B7 Avant 2.0 TDI 16V Brake Discs yourself – manuals and video tutorials

How to change front brake discs on Audi A4 B7 Avant – replacement guide

downloads: 1
Views: 16
Download your free tutorial and fix AUDI A4 Avant (8ED, B7) 2.0 TDI problems yourself Download for free 2.39 MB Brake Discs for Audi A4 B7 Avant Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your AUDI A4
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
AUDI A4 Avant (8ED, B7) 1.6, AUDI A4 Avant (8ED, B7) 2.0, AUDI A4 Avant (8ED, B7) 1.8 T, AUDI A4 Avant (8ED, B7) 1.8 T quattro, AUDI A4 Avant (8ED, B7) 2.0 TFSI, AUDI A4 Avant (8ED, B7) 2.0 TFSI quattro, AUDI A4 Avant (8ED, B7) 3.2 FSI, AUDI A4 Avant (8ED, B7) 3.2 FSI quattro, AUDI A4 Avant (8ED, B7) 1.9 TDI, AUDI A4 Avant (8ED, B7) 2.0 TDI 16V, AUDI A4 Avant (8ED, B7) 2.5 TDI, AUDI A4 Avant (8ED, B7) 3.0 TDI quattro, AUDI A4 Avant (8ED, B7) 2.0 TDI quattro, AUDI A4 Avant (8ED, B7) 2.0 TFSI, AUDI A4 Avant (8ED, B7) 2.0 TFSI quattro, AUDI A4 Avant (8ED, B7) 2.0 TDI, AUDI A4 Avant (8ED, B7) 2.0 TDI quattro, AUDI A4 Avant (8ED, B7) 2.7 TDI, AUDI A4 Avant (8ED, B7) 2.0 TDI, AUDI A4 Avant (8ED, B7) 3.0 TDI quattro, AUDI A4 Avant (8ED, B7) 2.0 TDI, AUDI A4 Avant (8ED, B7) 2.0 TFSI, AUDI A4 Avant (8ED, B7) 3.0 quattro, AUDI A4 Avant (8ED, B7) 3.0, AUDI A4 Avant (8ED, B7) 2.0 TDI, AUDI A4 Avant (8ED, B7) 2.0 TDI quattro, AUDI A4 Avant (8ED, B7) 2.7 TDi, AUDI A4 Avant (8ED, B7) 2.0 TDI … View more

The steps may slightly vary depending on the car design.

How to change front brake discs and front brake pads on AUDI A4 B7 AVANT TUTORIAL | AUTODOC

video
Published on: 10/12/2016
43K views
All the parts you need to replace – Brake Discs for A4 Avant (8ED, B7) and other AUDI models
Alternative products
How to change Brake disc on Audi A4 B7 Avant 2.0 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – Audi A4 B7 Avant. Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Sealant
Copper grease
Torx bit T30
HEX bit No.H7.
Drive socket # 21
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Flat Screwdriver
Crow bar
Tap wrench
Wheel chock
Buy tools
Replacement: brake discs – Audi A4 B7 Avant. AUTODOC experts recommend:
  • Replace the brake disks on the car Audi A4 B7 Avant in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – Audi A4 B7 Avant. Recommended sequence of steps:
  1. Step 1
    How to change Brake Discs on Audi A4 B7 Avant 2004 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    How to replace AUDI A4 Avant (8ED, B7) 2.0 TDI 2005 Brake Discs - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 3
    Audi A4 B7 Avant 2.0 TDI 16V 2006 Brake Discs replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  4. Step 4
    Changing Brake Discs on AUDI A4 Avant (8ED, B7) 2.0 TDI quattro 2007 by yourself
    Raise the front of the car and secure on supports.
  5. Step 5
    How to remove AUDI A4 2.0 TFSI quattro 2008 Brake Discs - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. Audi A4 B7 Avant
  6. Step 6
    How to replace Brake Discs on AUDI A4 Avant (8ED, B7) 2004: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 7
    How hard is it to do yourself: Brake Discs replacement on Audi A4 B7 Avant 1.8 T 2005 - download illustrated guide
    Detach the brake caliper retaining spring. Use a flat screwdriver.
  8. Step 8
    Need to know how to renew Brake Discs on AUDI A4 2006? This free workshop manual will help you to do it yourself
    Disconnect the ABS sensor. Use a flat screwdriver.
  9. Step 9
    Changing of Brake Discs on Audi A4 B7 Avant 2007 won't be an issue if you follow this illustrated step-by-step guide
    Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
  10. Step 10
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
    Step 11
    AUDI A4 2.0 TDI 16V Brake Discs replacement: online guides and video tutorials
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  11. Step 12
    Replacing Brake Discs on Audi A4 B7 Avant 2004 2.0 TDI by yourself
    Spread the brake pads. Use a crowbar.
  12. Step 13
    A4 Avant (8ED, B7) 2.0 TFSI quattro 2005 Brake Discs DIY replacement workshop manual
    Remove the brake caliper.
    Replacement: brake discs – Audi A4 B7 Avant. Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  13. Step 14
    How to change Brake Discs on AUDI A4 Avant (8ED, B7) 2006 - tips and tricks
    Remove the brake pads.
  14. Step 15
    Step-by-step recommendations for DIY replacement Audi A4 B7 Avant 2007 2.0 TFSI quattro Brake Discs
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – Audi A4 B7 Avant. After applying the spray, wait a few minutes.
  15. Step 16
    DIY replacement of Brake Discs on AUDI A4 Avant (8ED, B7) 1.9 TDI 2008 is not an issue anymore with our step-by-step tutorial
    Press in the brake caliper piston. Use brake caliper wind back tool.
  16. Step 17
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
    Step 18
    How to change Brake Discs on Audi A4 B7 Avant 2004 - free PDF and video manuals
    Unscrew the caliper bracket fastening. Use a drive socket #21. Use a ratchet wrench. Use a tap wrench.
  17. Step 19
    Remove the fastening bolts (2 pieces).
    Step 20
    How to replace AUDI A4 Avant (8ED, B7) 2.0 TDI 2005 Brake Discs - step-by-step manuals and video guides
    Remove the caliper bracket.
  18. Step 21
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
    Step 22
    Audi A4 B7 Avant 2.0 TDI 16V 2006 Brake Discs replacement: free workshop manuals
    Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
  19. Step 23
    Changing Brake Discs on AUDI A4 Avant (8ED, B7) 2.0 TDI quattro 2007 by yourself
    Remove the brake disc.
  20. Step 24
    How to remove AUDI A4 2.0 TFSI quattro 2008 Brake Discs - online easy-to-follow instructions
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  21. Step 25
    How to replace Brake Discs on AUDI A4 Avant (8ED, B7) 2004: download PDF manuals and video instructions
    Install the brake disc.
  22. Step 26
    How hard is it to do yourself: Brake Discs replacement on Audi A4 B7 Avant 1.8 T 2005 - download illustrated guide
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 5 Nm torque.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A4 B7 Avant (8ED) model

Audi A4 B7 Avant tyre size

Popular maintenance tutorials for Audi A4 B7 Avant

More manuals for Audi A4 B7 Avant

Complete guides for changing the Brake rotors on different AUDI A4 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI A4 Avant (8ED, B7) Brake Discs replacement - online guide
Tips & tricks for your AUDI A4 Avant (8ED, B7)
View more
  • How to change Brake rotors on AUDI A4 Avant (8ED, B7) 1.9 TDI - replacement tricks
    #DIY Wheel Rim Restoration: Revive Scratches and Chips Easily!
    7K views
    Published on: 18/07/2024
  • Changing Brake disc Audi A4 B7 Avant 2.0 TDI - Replacement Tips
    3 essential tips for choosing summer tyres | Get ready for warmer weather
    4K views
    Published on: 18/05/2023
  • Maintenance Hacks - AUDI A4 Avant (8ED, B7) 2.0 TDI 16V Rotors replacement guide
    What causes engine misfire? | AUTODOC
    6K views
    Published on: 10/07/2020
  • Replace Disc brakes on Audi A4 B7 Avant - free video tips
    5 mistakes made when washing the engine | AUTODOC tips
    31K views
    Published on: 22/04/2021

Most commonly replaced car parts on AUDI A4

Professional manuals for the most common AUDI models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI A4 Avant (8ED, B7) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME